2002 Chevrolet Prizm recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Suspension
What's wrong, in plain English: Parts can break and cause loss of control. 142435, 142193, 142305, 142303, SOLD AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE AFFECTED FRONT STRUT MOUNTS DID NOT CONTAIN A WELD JOINT BETWEEN THE BEARING HOUSING AND THE RATE PLATE.
What could happen: THE ABSENCE OF THE WELD CAN ALLOW THE STRUT TO COME OUT OF ITS MOUNTING POSITION UNDER CERTAIN EXTREME DRIVING CONDITIONS WHICH COULD CAUSE DAMAGE TO SURROUNDING VEHICLE COMPONENTS INCREASING THE RISK OF A CRASH.
The fix: RIDE CONTROL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED PARTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2010. OWNERS MAY CONTACT RIDE CONTROL AT 1-248-458-1396.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2002 PRIZM.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 10E002000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-248-458-1396.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SUSPENSION
Summary: RIDE CONTROL IS RECALLING CERTAIN FRONT STRUT MOUNTS BRANDED AS GABRIEL RIDE CONTROL OR ARVINMERITOR, P/NOS. 142435, 142193, 142305, 142303, SOLD AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE AFFECTED FRONT STRUT MOUNTS DID NOT CONTAIN A WELD JOINT BETWEEN THE BEARING HOUSING AND THE RATE PLATE.
Consequence: THE ABSENCE OF THE WELD CAN ALLOW THE STRUT TO COME OUT OF ITS MOUNTING POSITION UNDER CERTAIN EXTREME DRIVING CONDITIONS WHICH COULD CAUSE DAMAGE TO SURROUNDING VEHICLE COMPONENTS INCREASING THE RISK OF A CRASH.
Remedy: RIDE CONTROL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED PARTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2010. OWNERS MAY CONTACT RIDE CONTROL AT 1-248-458-1396.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET GABRIEL RIDE CONTROL OR ARVINMERITOR FRONT STRUT MOUNTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS, NISSAN, OR TOYOTA. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Engine (6), Electrical system (6), Airbags (4), Steering (4), Latches / locks (4).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
06/23/2018 · Engine
ENGINE ABSORBS OIL. AFTER PURCHASING; ENGINE SEIZED. PURCHASED 2ND ENGINE AT BEECHMONT CHEVROLET...SAME FLAW. ENGINE SEIZED AT FIVE MILE ROAD EXIT OFF OF I-275. TO THIS DAY IF I DO NOT CHECK OIL ON REGULAR BASIS. I POSE A RISK OF ENGINE SEIZING AGAIN.
06/23/2015 · Airbags
MY 2002 CHEVROLET PRIZM (SAME AS A TOYOTA COROLLA) HAS ITS CRUSE CONTROL, HORN, AND THE DRIVERS SIDE AIRBAG ALL MOUNTED ON THE STEERING WHEEL, ELECTRICALLY CONNECTED TO THE REST OF THE CAR THROUGH AN INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AKA CLOCK SPRING) MECHANISM. BOTH THE CRUSE CONTROL AND THE HORN DO NOT NOW OPERATE AND HAVEN'T FOR YEARS,…
01/30/2015 · Suspension
TL* THE CONTACT OWNS A 2002 CHEVROLET PRIZM. WHILE DRIVING AT 30 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT STRUTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10E002000 (SUSPENSION). T…
09/05/2010 · Electrical system
I HAVE A 02'CHEVY IMPALA WHEN I TURN IT ON ALL ELECTRIC COMES ON AND THE ENGINE RUNS FOR A SPLIT SECOND AND DIES THEN THE BATTERY LIGHT AND SERVICE TRACTION SYSTEM COMES ON I GOT THE FUEL PUMP AND SENSOR REPLACED STILL THE SAME PROBLEM OCCURS. I WAS ABLE TO DRIVE IT FOR A FEW MILES AFTER READING THE MANUAL AND PUSHING THE GAS TO THE FLOOR WHILE HOLDING THE…
08/10/2010 · Steering
2002 CHEVROLET PRIZM. CONSUMER STATES PROBLEM WITH STEERING WHEEL LOCKING UP *TGW
05/20/2010 · Electrical system
THIS IS A GENERAL POINT OF INFORMATION MESSAGE: FOR THE LAST DECADE OR MORE, GM VEHICLES HAVE A PROPENSITY TO BURN OUT THEIR LAMPS DUE TO AN OVERCHARGE CONDITION (CAUSE UNKNOWN TO ME); THIS CONDITION CAN AFFECT ANY OF THE LAMPS OR BULBS, MOST NOTICABLY HEADLAMPS, TAIL LIGHTS, AND RUNNING (PARKING) LAMPS. COULD YOU PLEASE INVESTIGATE THIS ELECTRICAL DEFECT I…
01/28/2010 · Engine
PURCHASED CAR JULY '09 WITH 64,000 ON ENGINE. VEHICLE PURCHASED WITH 90 DAY WARRANTY. 2700 MILES AFTER PURCHASE, ENGINE EMITTED BLUE SMOKE AFTER HIGHWAY DRIVING. VEHICLE TAKEN TO REPAIR SHOP, PISTONS HOLD NO COMPRESSION, ONE VALVE SHOT, REPAIR SHOP AND WARRANTY COMPANY STATE VEHICLE NOT DRIVABLE, NEEDS REPLACEMENT ENGINE, POTENTIAL VALVE DAMAGE., ENGINE COU…
12/08/2009 · Visibility (wipers / glass)
DEAR MADAM/SIR, IN TODAY'S (12/08/09) WALL STREET JOURNAL, IN THE ARTICLE ABOUT TOYOTA RECALLS, IT WAS MENTIONED THAT 2003 AND 2004 COROLLAS AND MATRIXES WERE RECALLED TO FIX A FLAW THAT COULD CAUSE THE POWER WINDOWS TO STOP WORKING. I OWN A 2002 PRIZM, WHICH I BELIEVE IS A COROLLA WITH A PRIZM BADGE. I HAD TO HAVE ONE POWER WINDOW FIXED AT 43,495 MILES,…