2002 Chevrolet Corvette recalls & complaints

Component: EXTERIOR LIGHTING:HEADLIGHTS
Summary: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: EXTERIOR LIGHTING
Summary: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
Summary: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes: GM RECALL NO. 04006. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

08/06/2025 · Steering
The contact owns a 2002 Chevrolet Corvette. The contact stated that while driving 5-10 MPH, the steering wheel locked-up, and the vehicle continued to drive in a circle. The steering column warning light was illuminated after the failure. The vehicle was towed to the local dealer, where the contact was informed that the vehicle was previously repaired unde…

03/01/2023 · Transmission / drivetrain
The ignition key started the car but the car continued to stall out when the clutch was released failing to propel the car leaving me stranded with a running(ideling) but non functional vehicle.I could not move the vehicle and it was subject to traffic crash. I need to have the vehicle retrieved by the dealer for repait. It is non-operable. There weree no w…

09/07/2020 · Steering
STEERING WHEEL IS LOCKED AFTER PARKING IT AFTER WORK. THE RECALL ON ALL OTHER VEHICLES MY YEAR THAT HAS BEEN FIXED BY THE FACTORY HAS A WIRE RAN TO THE PCM ARE COMPUTER NOT SURE WHAT THEY ARE CALLING IT. BUT THE FIX WILL NOT LET THE STEERING WHEEL LOCK. AND I HAVE WATCHED A LOT OF YOUTUBE VIDEOS ON THIS IN ALL OF THE FACTORY FIXED RECALLS THE STEERING WHEE…

02/25/2020 · Steering
I BOUGHT CAR OFF INTERNET NOT SURE IF ANY RECALLS HAVE BEEN DONE TRACTION CONTROLS SERVICE ABS STABILITY CONTROLS LIGHTS WILL NOT GO OFF TOLD THAT PARTS ARE DISCONTINUED YOU MAY REACH ME AT [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

09/03/2019 · Lights
DRIVING TO WORK (IN THE DARK) THE LOW BEAM HEADLIGHTS SHUT OFF. PULLED THE CAR OVER AND TURNED THE HEADLAMP SWITCH TO ON AND THEY STARTED WORKING (WAS IN AUTO SENSOR MODE). NEXT DAY WHEN I WAS LEAVING THE HOUSE I TURNED THE HEADLAMP SWITCH ON, HEADLIGHTS POPPED UP BUT DID NOT COME ON. I COULD TURN THEM TO HIGH BEAM AND THEY WORKED BUT NOT ON LOW. AFTER DRIV…

06/11/2019 · Steering
TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). AFTER THE REPAIR, THE STEERING WHEEL SEIZED WITHOUT WARNING AND A WARNING MESSAGE APPEARED, INDICATING TO REMOVE THE KEY AFTER TEN SECONDS. THE RECALL REPAIR WAS PERFORMED BY PAPE CHEVROLET GEO (370 OAKWOOD RD, HU…

04/22/2019 · Steering
I HAVE RECEIVED SEVERAL NOTICES FROM AUTO NATION CHEVROLET DORAL FLORIDA TO BRING MY CAR IN FOR RECALL GM 04006. WHEN I TOOK MY CAR TO THEM FOR THE RECALL, I WAS TOLD "THE PARTS REQUIRED FOR THE RECALL ARE NO LONGER MADE". I JUST RECEIVED ANOTHER NOTICE FROM THEM. THEY SHOULD EITHER MAKE THE PARTS OR COME TO ANOTHER RESOLUTION . I MEANWHILE CAN'T DRIVE TH…

11/23/2018 · Wheels / tires
NOTICED A SLIGHT VIBRATION COMING FROM REAR OF CAR WHEN DRIVING ON A PAVED SMOOTH ROAD AT 65 MPH. UPON LATER INSPECTION, I DISCOVERED A 2" LONG CRACKED LR WHEEL THE CRACK IS LOCATED AT THE BASE OF ONE OF 5 SLENDER SPOKES WHERE IT CONNECTS TO THE BARREL OF THE WHEEL. ANY RETAILER WHO LISTS THIS 18" FORGED ALUMINUM WHEEL IS OUT OF STOCK AS THIS UPGRADED WHEEL…