2002 Chevrolet Express recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2002 Chevrolet Express owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Brakes (16), Engine (13), Electrical system (12), Hydraulic (12), Wheels / tires (10).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
09/30/2021 · Suspension
The contact owns a 2002 Chevrolet Express. The contact stated while driving 65 MPH, she heard an abnormal loud banging sound coming from the rear end of the vehicle. The contact stated that the passenger’s side rear axle detached from the vehicle, causing the tire to detach and roll away. The contact did not sustain any injury. The vehicle was towed to a to…
02/11/2021 · Suspension
2002 CHEVROLET EXPRESS 3500. CONSUMER WRITES IN REGARDS TO BROKEN DRIVERS SIDE SPRING LEAF. *LD THE CONSUMER STATED AFTER A POTHOLE BROKE THE SPRING LEAVE, IT WAS DISCOVERED THAT SPRING LEAF WAS INCORRECTLY INSTALLED BY THE FACTORY. *JS
08/05/2018 · Body / structure
THE SIDE HINGES SEIZE UP AND BREAK. IT THROWS THE DOOR ALIGNMENT OFF AND I AM NO LONGER ABLE TO COMPLETELY CLOSE THE FRONT SIDE DOOR AND IT KEEPS THE PASSENGER DOOR FROM OPENING ALSO. THIS IS A CONTINUEING PROBLEM CHEVROLET HAS WITH THEIR EXPRESS VANS. IT IS A DESIGN PROBLEM AND ALSO CHEAP MATERIALS CAUSED IT TO RUST AND SEIZE UP AND THEN BREAK THE HINGE,…
11/29/2016 · Brakes
2 DAYS AGO I WAS DRIVING ON THE BALTIMORE BELTWAY TRAFFIC MADE AN ABRUPT STOP I HIT MY BRAKES AND THE PEDAL WENT TO THE FLOOR LUCKILY I WAS IN THE RIGHT LANE AND COULD USE MY PARKING BRAKE AND DOWNSHIFTING TO GET OFF THE ROAD. I WAS ABLE TO GET OFF THE NEXT EXIT AND TAKE BACK ROADS HOME USING MY PARKING BRAKE TO STOP. *TR
08/19/2015 · Seat belts
REAR SEAT BELTS FAIL TO LOCK MY VEHICLE IS A CONVERSION VAN BUILT BY DEBUT IN SAGINAW MICHIGAN. RECENTLY MY GRANDCHILDREN NOTICED THAT THE REAR SEAT BELTS FAILED TO LOCK. THOSE BELTS ARE ON THE SEAT/BED UNIT. THE SEAT BELTS HAVE THE NAME ATWOOD MOBILE PRODUCTS ON THEM. I INSPECTED THE SEAT BELTS AND DETERMINED THAT THE PLASTIC COATING ON THE MALE END…
08/08/2015 · Body / structure
WHEN I CAME OUTSIDE THE GLASS WAS BROKEN AND HAD BEEN THROWN TO THE OUTSIDE OF THE VEHICLE. THE VEHICLE HAD BEEN DRIVEN THE DAY BEFORE AND WAS FINE. IT WAS PARKED IN THE SHADE AND AWAY FROM ANYTHING WHICH COULD HAVE HIT IT. IT WAS LOCKED AND NOT TOUCHED IN ANY WAY. THE BROKEN FRAGMENTS WERE ON THE GROUND BELOW THE GLASS FRAME AREA. IT IS THE SAME TYPE OF GL…
06/24/2014 · Wheels / tires
TIRES HAD MORE THAN 50% TREAD LEFT. RIGHT FRONT TIRE SUDDENLY STARTED SHAKING THE VEHICLE. DETERMINED BELT HAD BROKE. TIRE DEALER ALSO SAID OTHER FRONT TIRE WAS GOING BAD. A FEW MILES LATER ON A BUSY HIGHWAY READ TIRE SPLIT OPEN . PERFORMANCE TIRE OF TOPEKA AND COOPER TIRE COMPANY WOULD NOT MAKE ANY ADJUSTMENT FOR AN OBVIOUS DEFECT. (3 OUT OF 4 TIRES BREAKI…
09/18/2013 · Brakes
BRAKES FAILED WITH NO WARNING. UPON INSPECTION IT WAS DETERMINED THAT BRAKE LINES BURST DUE TO RUSTING.