2002 Chevrolet Envoy recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2002 Chevrolet Envoy owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (5), Airbags (4), Electrical system (3), Visibility (wipers / glass) (3), Engine (3).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
11/09/2017 · Airbags
TL* THE CONTACT OWNS A 2006 (NA) CHEVROLET ENVOY. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 178,111.
08/11/2017 · Fuel system
FUMES CAME INSIDE OF THE CAR BECAUSE THE FUEL TANK LEAKS....COULD BE RUNNING OR STATIONARY...
12/05/2015 · Fuel system
FUEL LEAKING FROM ABOVE THE TANK. SEEMS TO BE PUDDELING ON TOP AND SPILL OFF DURING TURNS AND ACCELERATION. IN PARKED POSITION, FUEL DRIPS AT A FAST PACE ESTIMATED AT 1 DRIP PER SECOND. LEAK IS AGGRESSIVE AND POSES AN EXTREME DANGER AND POSSIBLE LOSS OF LIFE.
02/02/2015 · Airbags · crash
TL* THE CONTACT OWNED A 2002 CHEVROLET ENVOY. WHILE DRIVING APPROXIMATELY 40 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE, SLID OFF THE ROAD, AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED UNKNOWN INJURIES AND REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED AND TOWED TO AN IMPOUND LOT. THE VEHI…
10/29/2014 · Electrical system
TL* THE CONTACT OWNS A 2002 CHEVROLET ENVOY. THE CONTACT STATED THAT THE DRIVER SIDE MASTER POWER SWITCH FOR THE WINDOWS AND DOORS FAILED. THE CONTACT MENTIONED THAT THE WINDOWS FAILED TO OPEN OR CLOSE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 12V406000 (ELECTRICAL SYSTEM, VISIBILITY) AND NHTSA CAMPAIGN NUMBER…
12/08/2009 · Visibility (wipers / glass)
TL* THE CONTACT OWNS A 2002 CHEVROLET ENVOY. WHILE DRIVING APPROXIMATELY 35 MPH IN RAINY WEATHER CONDITIONS, THE FRONT WINDSHIELD WIPER SELECTOR ACTIVATED IN THE DELAY MODE. CONSEQUENTLY HE COULD NOT ENGAGED THE WIPERS IN FULL SPEED. THE VEHICLE WAS PARTIALLY REPAIRED ACCORDING TO RECALL CAMPAIGN ID NUMBER 04V046000 (VISIBILITY;WINDSHIELD WIPER/WASHER).…
04/26/2005 · Brakes
2002 GMC ENVOY EXPERIENCING PROBLEMS WITH BRAKE WEAR.*MR THE ROTORS WERE CRACKING AT THE EDGES. THE CONSUMER WROTE GMC AND THEY CALLED AND OFFERED A INCENTIVE TO PURCHASE A NEW GM VEHICLE. THE CONSUMER FEELS THE STEEL USED TO MANUFACTURE THE ROTOR IS POOR QUALITY. *BF *NM
01/03/2005 · Visibility (wipers / glass)
THE AUTOMATIC ADJUSTING SIDE VIEW MIRROR FAILED. THE MIRROR WILL NOT ADJUST WHEN THERE'S A NEW DRIVER. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK