2009 Volvo Xc90 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires.
What could happen: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
The fix: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2009 XC90.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 10V566000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
Summary: VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Notes: VOLVO SAFETY RECALL NO. R231. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2009 Volvo Xc90 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (3), Brakes (2), Fuel system (1), Vehicle Speed Control (1), Unknown Or Other (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (7)
01/17/2023 · Fuel system
A plastic Fuel Pressure Sensor bracket holder, part number: 30720139, found on Volvo V8 XC90 and S80 (2005-2011) can crack, resulting in a fuel leak within the engine compartment. See attached picture of 30720139, with highlight of plastic assembly. No replacement part is available from Volvo, since ~Dec 2021, per this link: https://www.swedespeed.com/th…
10/07/2021 · Vehicle Speed Control
I have installed a SprintDrive installed in my Volvo. Since the installation, I have had several safety and security issues occur that stop once the device is removed. The following issues have occurred: 1) Whilst driving on the Muskogee Turnpike, the cruising control system would disengage. This occurred at least three times during the drive. On the th…
08/15/2017 · Wheels / tires
REAR SPARE TIRE DROPPED OFF VEHICLE IN TRAFFIC SLIDING ACROSS THE FREEWAY, CATASTROPHIC FAILURE OF CABLE HOLDING REAR TIRE UNDER THE VEHICLE
12/02/2015 · Body / structure
OPENED TRUNK HATCH DOOR TO PUT ITEMS IN TRUNK AND LIFTED DOOR TO THE FULL OPEN POSITION, THE HYDRAULIC ARMS BOTH FAILED AND THE FULL WEIGHT OF THE DOOR FELL DIRECTLY ONTO HEAD CAUSING SEVERE HEAD INJURY WITH RESIDUAL EFFECTS. NO PROBLEMS WITH TRUNK DOOR PRIOR TO THIS.
02/25/2015 · Electrical system
TL* THE CONTACT OWNS A 2009 VOLVO XC90. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT ABLE TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER. THE CONTACT WAS UNAWARE OF THE REPAIRS THAT WERE PERFORMED ON THE VEHICLE. THE FAILURE RECURRED AND A FUSE WAS REPLACED; HOWEVER, THE FAILURE RECURRED AND THE ECM MODULE NE…
04/19/2014 · Electrical system
DURING SWITCHING OFF IGNITION A WARNING LIGHT WAS VISIBLE, ON TURNING ON IGNITION AGAIN MULTIPLE FAULTS REGISTERED ON THE INSTRUMENT CLUSTER.NO ISSUES PRIOR TO THIS FAULT OCCURRED. LIST OF FAULTS NOTICED: 1: SRS WARNING LIGHT (INSTRUMENT CLUSTER NOTIFICATION) 2: ABS FAILURE (INSTRUMENT CLUSTER NOTIFICATION) 3: PASSENGER AIRBAG OFF (INSTRUMENT CLUSTER NO…
05/25/2012 · Electrical system
TL* THE CONTACT OWNS A 2009 VOLVO XC90. THE CONTACT STATED THAT THE VEHICLE HAD BEEN SITTING IDLE FOR FOUR DAYS. AFTER FOUR DAYS, THE CONTACT ATTEMPTED TO START THE VEHICLE BUT TO NO AVAIL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS HOWEVER THE ELECTRICAL DRAIN COULD NOT BE LOCATED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 32,000 AND THE…