1994 Mitsubishi Galant recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Suspension
What's wrong, in plain English: Parts can break and cause loss of control. VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
What could happen: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
The fix: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 GALANT.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 99V066001.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.
Notes: OWNER NOTIFICATION BEGAN JUNE 15, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
2. Suspension
What's wrong, in plain English: Parts can break and cause loss of control. VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
What could happen: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
The fix: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 GALANT.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 00V421001.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Remedy: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.
Notes: OWNER NOTIFICATION WILL BE CONDUCTED IN PHASES. THE FIRST PHASE BEGAN APRIL 2, 2001, AND THE FINAL PHASE WILL BE COMPLETED ON SEPTEMBER 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AMERICA AT 1-888-MITSU-2001 (1-888-648-7820). ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.
What could happen: IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
The fix: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 GALANT.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 07E055000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.
Consequence: IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
Remedy: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.
Notes: AIRTEX RECALL NO. FP072007-1. THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY DAIMLERCHRYSLER OR MITSUBISHI. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
4. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. VEHICLE DESCRIPTION: PASSENGER VEHICLES. WHEN THE STOP LAMP SWITCH WAS ASSEMBLED, GREASE WAS INADVERTENTLY APPLIED TO THE CONTACT POINT. THIS CAN CAUSE THE CONTACT POINT TO HEAT UP CAUSING INTERNAL OPERATION ELEMENTS TO MELT ALLOWING THE SWTICH TO BECOME STUCK IN ON OR OFF POSITION.
What could happen: THIS CONDITION CAN CAUSE THE ANTI-LOCK BRAKING SYSTEM (ABS) WARNING LIGHT TO COME ON.
The fix: DEALERS WILL INSTALL A RELAY AND REPLACE THE BRAKE LAMP SWITCH.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 GALANT.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 98V212000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:TAIL LIGHTS:SWITCH
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. WHEN THE STOP LAMP SWITCH WAS ASSEMBLED, GREASE WAS INADVERTENTLY APPLIED TO THE CONTACT POINT. THIS CAN CAUSE THE CONTACT POINT TO HEAT UP CAUSING INTERNAL OPERATION ELEMENTS TO MELT ALLOWING THE SWTICH TO BECOME STUCK IN ON OR OFF POSITION.
Consequence: THIS CONDITION CAN CAUSE THE ANTI-LOCK BRAKING SYSTEM (ABS) WARNING LIGHT TO COME ON.
Remedy: DEALERS WILL INSTALL A RELAY AND REPLACE THE BRAKE LAMP SWITCH.
Notes: OWNER NOTIFICATION BEGAN NOVEMBER 30, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1994 Mitsubishi Galant owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Suspension (62), Airbags (42), Transmission / drivetrain (28), Brakes (20), Hydraulic (19).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
06/20/2016 · Wheels / tires
PURCHASED 3 TIRES JUNE 18TH 2016. BY THE END OF THE DAY MY SPARE TIRE WAS COMPLETELY EMPTY I TOOK IT BACK AND HAD A NEW ONE PUT BACK ON IT. JUNE 19TH THE TIRE THAT WAS PUT ON MY CAR ALSO WENT FLAT WHILE SITTING IN A PARKING LOT. I DECIDED TO FILE THIS FORMAL COMPLAINT DUE TO THE FACT THAT THEY REFUSED TO GIVE ME A REFUND OF $30 FOR THE BAD TIRE. ALSO DUE T…
11/23/2009 · Airbags
FRONTAL AUTO ACCIDENT 1994 MITSIBISHI GALANT LS AIR BAGS DID NOT DEPLOY! *TR
08/08/2007 · Suspension
THE WHEEL OF MY DAUGHTER'S MITSUBISHI GALANT FELL OFF! WHILE PULLING INTO THE DRIVEWAY AT OUR HOME, THE GALANT'S BALL JOINT ON THE LOWER LATERAL CONTROL ARM FAILED. THE BALL JOINT PULLED OUT OF THE SOCKET AND THE TRANSAXLE PULLED OUT OF THE TRANSMISSION. THIS RESULTED IN THE WHEEL FALLING AGAINST THE WHEEL WELL (LITERALLY FALLING OFF THE CAR!) THERE WAS…
11/24/2006 · Suspension
A NEAR MISS. THE NUT ON THE LOWER CONTROL ARM CAME OFF ON DRIVERS SIDE. 75 MPH AND THANK GOODNESS I WAS STRONG TO PULL THE ASPHALT EATING FRONT END TO THE SIDE. GOING DOWNHILL HEARD WHAT WAS THOUGHT TO BE A PEBBLE HIT THE UNDERSIDE OF THE CAR AND THEN WAS BEING PULLED UNDER THE ONCOMING SEMI. UPON FINALLY STOPPING ON THE SHOULDER, I GOT OUT LOOKED AT MY TIR…
10/17/2005 · Steering
PURSUANT TO THE BALL JOINT RECALL FOR MY 1994 MITSUBISHI GALANT, I TOOK MY CAR TO OURISMAN MITSUBISHI IN 2004 WHO THEN INSPECTED THE BOOT, NOTICED THE BOOT WAS BROKEN YET THE SERVICEMAN RESEALED THE BOOT AND INFORMED ME THAT THE CAR WAS CHECKED AND THE LOWER CONTROL ARMS WERE INTACT. IN AUGUST 2005, WHILE I WAS HAVING MY CAR SERVICE FOR A WATER PUMP PROBLE…
10/07/2005 · Suspension
DURING REPLACEMENT OF STRUTS SERVICE TECHNICIAN NOTICED THAT BALL JOINTS HAD EXCESSIVE PLAY. *TS THE MANUFACTURER HAS RECALLED MANY BALL JOINTS RECALL #SR-04-001 ACCORDING TO ALLDATA. *NM
08/17/2005 · Suspension
I RECEIVED A RECALL NOTICE FOR MY 1994 MITSUBISHI GALANT LS ,AND I TOOK MY CAR TO THE NEAREST DEALERSHIP, OURISMAN MITSUBISHI, LAST YEAR CONCERNING THE LOWER ARM BALL JOINT. IT WAS DETERMINED THERE THAT THE BALL JOINT WAS IN EXCELLENT CONDITION. AFTER HAVING MY CAR INSPECTED BY MY PRIVATE AND CERTIFIED MECHANIC HE STRONGLY RECOMMENDED THAT I REPLACE THIS…
06/21/2005 · Electrical system
DT: CALLER SAYS THE CAR STALLED AT ANY SPEED. THIS HAPPENED WITHOUT WARNING. DEALER COULD NOT FIND WHAT WAS WRONG WITH VEHICLE. THEY COULD NOT REPLACE PARTS UNTIL THEY FIND THE ONE THAT WORKED MANUFACTURER HAS NOT BEEN CONTACTED YET. CAR HAD TO BE TOWED TWICE. *AK