1996 Mitsubishi Galant recalls & complaints

Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. CRACKS CAN OCCUR IN THE TOP OF THE FUEL TANK DUE TO AN IMPROPER SPOT WELD ON THE BAFFLE PLATE TO THE TOP PORTION OF THE FUEL TANK.
Consequence: A CRACK IN THE FUEL TANK COULD ALLOW FUEL OR FUMES TO ESCAPE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE UPPER SURFACE OF THE FUEL TANK FOR ANY SIGNS OF CRACKING. IF NO CRACKING OR LEAKING IS FOUND, DEALERS WILL INSTALL A SEALING PROTECTOR PLATE. IF ANY CRACKING OR LEAKAGE IS FOUND, DEALERS WILL REPLACE THE FUEL TANK ASSEMBLY.
Notes: OWNER NOTIFICATION BEGAN SEPTEMBER 25, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Remedy: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.
Notes: OWNER NOTIFICATION WILL BE CONDUCTED IN PHASES. THE FIRST PHASE BEGAN APRIL 2, 2001, AND THE FINAL PHASE WILL BE COMPLETED ON SEPTEMBER 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AMERICA AT 1-888-MITSU-2001 (1-888-648-7820). ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.
Notes: OWNER NOTIFICATION BEGAN JUNE 15, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.
Consequence: IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
Remedy: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.
Notes: AIRTEX RECALL NO. FP072007-1. THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY DAIMLERCHRYSLER OR MITSUBISHI. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

04/26/2012 · Body / structure
TL* THE CONTACT OWNS A 1996 MITSUBISHI GALANT. THE CONTACT STATED THAT ROUTINE MAINTENANCE WAS BEING PERFORMED ON THE VEHICLE WHEN SHE WAS NOTIFIED THAT THE FRAME WAS CORRODED. THE MECHANIC STATED THAT THE VEHICLE NEEDED TO BE DESTROYED AND WAS NO LONGER SAFE TO OPERATE. THE DAMAGE WAS BEYOND REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID N…

01/08/2011 · Transmission / drivetrain
MY MITSUBISHI MAGNA 1996 HAD VERY LITTLE MECHANICAL PROBLEMS BEFORE LAST YEAR WHEN I WAS DRIVING ALONG AND NOTICED AND OVERREV AND SUDDEN BUMP INTO 3RD GEAR AND OVER TIME IT FADED OUT TO NOTHING AND THEN I WAS DRIVING IT AND THEN LOST 3RD GEAR COMPLETELY...IT TRYS TO GO INTO THE 3RD GEAR BUT WON'T GO IN AND FALLS INTO NEUTRAL I'VE ASKED MANY AUTO TRANSMISSI…

08/30/2010 · Suspension
I CURRENTLY BOUGHT THE 1996 MITSUBISHI GALANT FOR MY WIFE AND 11 MONTH OLD DAUGHTER. THE DEALER TOLD ME I NEEDED A FRONT END ALIGNMENT TO GET THE PULL AND SHAKE OUT OF MY FRONT END. I TOOK IT TO AN ALIGNMENT SHOP AND THE ASE MASTER TECH. TOLD ME MY CONTROL ARMS WERE BENT DUE TO CORROSION OF THE BALL JOINT, HE THEN TOLD ME THERE WAS A RECALL ON THESE VEHICL…

05/13/2008 · Body / structure
TL*THE CONTACT OWNS A 1996 MITSUBISHI GALANT. WHILE ATTEMPTING TO CHANGE A FLAT TIRE, THE JACK WENT STRAIGHT THROUGH THE FRAME WHILE THE VEHICLE WAS BEING LIFTED. THE CONTACT HAD THE VEHICLE TOWED TO A SHOP AND THEY INFORMED HIM THAT THERE WAS EXCESSIVE RUST IN THE REAR SUBFRAME. THE CONTACT SOLD THE VEHICLE RATHER THAN HAVE IT REPAIRED. THE FAILURE MIL…

12/04/2007 · Body / structure
TL*THE CONTACT OWNS A 1996 MITSUBISHI GALANT. THE REAR WHEEL ASSEMBLY IS ATTACHED TO THE SUBFRAME, WHICH IS ATTACHED TO THE BODY. THE ENTIRE PART IS EXTREMELY RUSTED AND PREVENTED THE CONTACT FROM JACKING THE VEHICLE AND CHANGING THE TIRE. THE DEALER NOTIFIED THE CONTACT OF THIS FAILURE. THE FAILURE IS NOTICEABLE WHILE DRIVING 20 MPH. THE FAILURE MILEA…

11/17/2007 · Body / structure
THE REAR UNDERCARRIAGE OF MY 1996 MITSUBISHI GALANT HAS SEVERE RUST DAMAGE TO THE POINT THAT YOU CANNOT EVEN JACK UP THE CAR AS THE JACK PENETRATES THEY SUB FRAME. THE STRUT FROM THE RIGHT REAR ALSO CAME LOOSE FROM THE TOWER. THE REAR WHEELS THAT ARE ATTACHED TO THE SUB FRAME ARE EXTREMELY UNSAFE. *TR

02/06/2007 · Body / structure
TL* - THE CONTACT OWNS A 1996 MITSUBISHI GALANT. DURING ROUTINE MAINTENANCE CHECKS THE MECHANIC DISCOVERED RUST ON THE FRAME UNDER THE VEHICLE IN FRONT OF EACH REAR WHEEL. THE CURRENT MILEAGE WAS 157000 AND THE FAILURE MILEAGE WAS 155000. *AK UPDATED 2/27/2007 - *NM

11/29/2005 · Suspension
BOTH BALL JOINTS ON THE CONSUMERS 1996 MITSUBISHI GALANT FAILED, BREAKING THE DRIVE AXLE. *TS AFTER DOING SOME RESEARCH, THE CONSUMER DISCOVERED A RECALL HAD BEEN ISSUED FOR THE BALL JOINTS. THE CONSUMER NEVER RECEIVED ANY TYPE OF NOTIFICATION. THE CONSUMER WAS TOLD BY THE MANUFACTURER THAT THE RECALL WORK HAD ALREADY BEEN DONE, HOWEVER THAT PROVED TO BE…