2022 Kia Carnival recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
6 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. The plastic fuel rail tube may have been damaged.
What could happen: A damaged fuel rail tube may leak fuel, increasing the risk of a fire.
The fix: Kia will notify owners, and dealers will inspect, and if necessary, replace the multi-port injection fuel rail, free of charge. The recall began April 30, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC211.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2022 CARNIVAL.
- Book a repair at any authorized Kia dealer. Quote NHTSA campaign 21V277000 (manufacturer code SC211).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-333-4542.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
Summary: Kia Motors America (Kia) is recalling certain 2022 Carnival vehicles. The plastic fuel rail tube may have been damaged.
Consequence: A damaged fuel rail tube may leak fuel, increasing the risk of a fire.
Remedy: Kia will notify owners, and dealers will inspect, and if necessary, replace the multi-port injection fuel rail, free of charge. The recall began April 30, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC211.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
2. Trailer Hitches
What's wrong, in plain English: A vehicle part that may fail. Kia America, Inc. (Kia) is recalling certain 2022-2023 Carnival vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
What could happen: A fire while parked or driving can increase the risk of injury.
The fix: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will inspect and verify whether the vehicle is equipped with a Genuine Kia accessory trailer tow hitch assembly. If equipped, dealers will install a new fuse and wire extension kit. Repairs will be perf…
What to do
- Park outside, away from houses, garages and other cars — there is a fire risk even when the vehicle is off.
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2022 CARNIVAL.
- Book a repair at any authorized Kia dealer. Quote NHTSA campaign 23V179000 (manufacturer code SC265).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-333-4542.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: TRAILER HITCHES
Summary: Kia America, Inc. (Kia) is recalling certain 2022-2023 Carnival vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will inspect and verify whether the vehicle is equipped with a Genuine Kia accessory trailer tow hitch assembly. If equipped, dealers will install a new fuse and wire extension kit. Repairs will be performed free of charge. Owner notification letters were mailed May 16, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC265.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
3. Body / structure
What's wrong, in plain English: Body panels, frame, doors, hood, trunk or latches. The roof molding may loosen and detach.
What could happen: A detached roof molding can create a road hazard for other vehicles, increasing the risk of a crash.
The fix: Dealers will inspect the roof molding and replace or secure it as necessary, free of charge. Owner notification letters were mailed March 15, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC292.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2022 CARNIVAL.
- Book a repair at any authorized Kia dealer. Quote NHTSA campaign 24V025000 (manufacturer code SC292).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-333-4542.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STRUCTURE:BODY:ROOF AND PILLARS
Summary: Kia America, Inc. (Kia) is recalling certain 2023-2024 Sportage and 2022-2024 Carnival vehicles. The roof molding may loosen and detach.
Consequence: A detached roof molding can create a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Dealers will inspect the roof molding and replace or secure it as necessary, free of charge. Owner notification letters were mailed March 15, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC292.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
4. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. Fuel may leak at the pipe connection between the fuel pipe and fuel rail.
What could happen: A fuel leak increases the risk of a fire.
The fix: Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed June 2, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC368. Vehicle Identification Numbers (VINs) involved in this recall will be searchabl…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2022 CARNIVAL.
- Book a repair at any authorized Kia dealer. Quote NHTSA campaign 26V232000 (manufacturer code SC368).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-333-4542.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary: Kia America, Inc. (Kia) is recalling certain 2022-2026 Carnival vehicles. Fuel may leak at the pipe connection between the fuel pipe and fuel rail.
Consequence: A fuel leak increases the risk of a fire.
Remedy: Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed June 2, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC368. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on April 24, 2026.
Notes:
5. Latches / locks
What's wrong, in plain English: Doors, hood or trunk may open unexpectedly. The remote controller assembly for the passenger-side power sliding door may malfunction, preventing the passenger-side sliding door from securely latching.
What could happen: A power sliding door that fails to latch may open while moving, increasing the risk of injury.
The fix: Dealers will replace the passenger-side power sliding door release actuator's drum and holder inside the remote controller assembly, free of charge. Owner notification letters were mailed December 16, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC221.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2022 CARNIVAL.
- Book a repair at any authorized Kia dealer. Quote NHTSA campaign 21V908000 (manufacturer code SC221).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-333-4542.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: LATCHES/LOCKS/LINKAGES:ELECTRONIC LOCK/LATCH ACTUATOR
Summary: Kia Motors America (Kia) is recalling certain 2022 Carnival vehicles. The remote controller assembly for the passenger-side power sliding door may malfunction, preventing the passenger-side sliding door from securely latching.
Consequence: A power sliding door that fails to latch may open while moving, increasing the risk of injury.
Remedy: Dealers will replace the passenger-side power sliding door release actuator's drum and holder inside the remote controller assembly, free of charge. Owner notification letters were mailed December 16, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC221.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
6. Body / structure
What's wrong, in plain English: Body panels, frame, doors, hood, trunk or latches. The auto-reverse feature for the power sliding doors (PSD) may not activate in all situations.
What could happen: A power sliding door that does not auto-reverse can close on an occupant, increasing the risk of injury.
The fix: Dealers will update the power sliding door control module software, free of charge. Owner notification letters were mailed April 28, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC266.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2022 CARNIVAL.
- Book a repair at any authorized Kia dealer. Quote NHTSA campaign 23V236000 (manufacturer code SC266).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-333-4542.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STRUCTURE:BODY:DOOR
Summary: Kia America, Inc. (Kia) is recalling all 2022 and certain 2023 Carnival vehicles. The auto-reverse feature for the power sliding doors (PSD) may not activate in all situations.
Consequence: A power sliding door that does not auto-reverse can close on an occupant, increasing the risk of injury.
Remedy: Dealers will update the power sliding door control module software, free of charge. Owner notification letters were mailed April 28, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC266.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2022 Kia Carnival owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Unknown Or Other (35), Body / structure (34), Electrical system (23), Visibility (wipers / glass) (19), Engine (17).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
09/29/2026 · Unknown Or Other
On June 20, 2026, the instrument cluster in my 2022 Kia Carnival became completely inoperative. The failure prevents me from viewing vehicle speed, fuel level, gear position, warning indicators, mileage, and other information normally displayed by the cluster. Because the cluster is the driver's primary source for operating and warning information, I believ…
09/22/2026 · Electrical system
The power sliding door actuator motor drive cables on my 2022 Kia Carnival snapped on both the passenger and driver sides. The doors are stuck shut, even in manual mode, creating a safety hazard for passengers since the only way to exit in an accident would be through the rear hatch or the front doors. The Kia dealer said they couldn’t open the doors withou…
09/15/2026 · Body / structure
The rear latch on both sliding doors rusts and the buildup prevents the door from closing eventually because the latch mechanism stays up. There is a video on this from a Kia master tech.
08/01/2026 · Unknown Or Other
The power sliding door on my Kia Carnival has repeatedly failed to reopen when an occupant was caught in the doorway. On multiple occasions, my young child has become trapped by the sliding door after it began closing. Instead of consistently detecting the obstruction and reversing as expected, the door continued to close and pinned my child until an adult…
07/27/2026 · Body / structure
The contact owns a 2022 Kia Carnival. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 21V908000 (Latches/Locks/Linkages, Structure); however, the failure persisted. The contact stated that the rear passenger’s side power sliding door failed to latch securely. The contact used force while pushing the rear passenger’s…
07/04/2026 · Fuel system
SC368 CROSS OVER FUEL PIPE recall incomplete by kia of des moines
06/12/2026 · Fuel system
I am writing to formally complain about the delay in repairing my vehicle under an active recall involving the fuel system/crossover fuel pump. I have been informed that the required part is on backorder and that the repair may not be available until the end of July. My concern is that I am experiencing strong fuel fumes in and around the vehicle. The odor…
06/04/2026 · Fuel system
Fuel leak at pipe connection between the fuel pipe and fuel rail. Nuts securing the high-pressure crossover fuel pipe to the fuel rail loosened, leaking raw fuel, leading to risk of fire. This has been reported and confirmed by Ron Bouchard Kia, of Lancaster, MA, USA. It is a part of Kia Recall SC368 (NHTSA ID: 26V232). We noticed the vehicle was leak…