2004 Hyundai Elantra recalls & complaints

Component: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary: DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST, IT WAS DETERMINED THAT FUEL TAN DAMAGE COULD OCCUR. ON CERTAIN PASSENGER VEHICLES, A VAPOR TUBE HOSE CLAMP THAT IS LOCATED NEAR THE FUEL TANK MAY NOT BE POSITIONED PROPERLY AND COULD CAUSE FUEL LEAKAGE.
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP EARS AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
Notes: HYUNDAI RECALL NO. 067. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: AIR BAGS
Summary: CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.
Consequence: THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON NOVEMBER 15, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
Notes: HYUNDAI PR RECALL NO. 073. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: AIR BAGS
Summary: CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.
Consequence: THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON OCTOBER 31, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Notes: HYUNDAI RECALL NO. 073. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: AIR BAGS
Summary: ON CERTAIN VEHICLES, IF THE FRONT PASSENGER SEAT IS UNOCCUPIED OR IS OCCUPIED BY SOMEONE LIGHTER THAN 56.4 POUNDS, THE PASSENGER AIR BAG IS DEACTIVATED AND WILL NOT DEPLOY IF A CRASH OCCURS. HOWEVER, THE OCCUPANT CLASSIFICATION SENSOR MAY INCORRECTLY INTERPRET THAT A SEATED ADULT IS AN INFANT SEAT AND DEACTIVATE THE PASSENGER AIR BAG IF SOMEONE HEAVIER THAN 56.4 POUNDS WHO IS SEATED WITH ONE LEG RESTING ON THE OUTBOARD OR INBOARD EDGE OF THE SEAT; WITH LEGS SPREAD; OR POSITIONED OFF-CENTER TOWARD THE CENTER CONSOLE AND WITH HIS OR HER ARM LEANING ON THE CONSOLE.
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE AIR BAG MAY NOT DEPLOY, POSSIBLY RESULTING IN SERIOUS INJURY TO THE RIGHT FRONT PASSENGER.
Remedy: THE OCCUPANT CLASSIFICATION SENSOR WILL BE REPROGRAMMED.
Notes: HYUNDAI RECALLNO. 062. ALL AFFECTED VEHICLES WERE DELIVERED TO ENTERPRISE RENT-A-CAR AND WILL NOT BE PLACED IN SERVICE UNTIL THE RECALL REPAIR WORK IS COMPLETE. CUSTOMER NOTIFICATION FOR THIS CAMPAIGN IS NOT NECESSARY. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary: DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST ON CERTAIN PASSENGER VEHICLES, FUEL SPILLAGE OCCURRED AS A RESULT OF FUEL TANK DAMAGE CAUSED BY CONTACT BETWEEN A VAPOR TUBE HOSE CLAMP EAR AND THE FUEL TANK. THE VAPOR TUBE HOSE CLAMP EAR WAS FOUND TO BE MISPOSITIONED AND FACING TOWARD THE FUEL TANK.
Consequence: IN THE EVENT OF A CRASH, DAMAGE TO THE VEHICLE COULD CAUSE THE MISPOSITIONED CLAMP TO PUNCTURE THE FUEL TANK CAUSING FUEL LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. OWNER NOTIFICATION BEGAN ON MAY 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Notes: HYUNDAI RECALL NO. 067. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

02/01/2024 · Suspension
Rapid rusting of rear subframe cross member. Car rarely gets driven in snow or even bad weather. Went from minimal signs of rust to looking pretty rotted within the past year. Saw recalls on similar Hyundai vehicles. Maybe possible the same steel was used, or same lack of corrosion preventative.

06/14/2019 · Airbags · crash
VEHICLE 2004 HYUNDAI INVOLVED IN ACCIDENT ON THE STREET, THIS VEHICLE OWNER WAS BELTED WHEN THE ACCIDENT OCCURRED, THE AIRBAGS DEPLOYED, THIS VEHICLE OWNER SUSTAINED SEVERE INJURIES INCLUDING FRACTURED VERTEBRATE OF LUMBAR 1 AND 2 AND FRACTURED RIBS, NOTE NO OTHER VEHICLE WAS INVOLVED, THIS VEHICLE OWNER SIDE SWIPED A TREE AND SUSTAINED MINIMAL DAMAGE TO TH…

02/26/2019 · Airbags
SRS (AIRBAG) SERVICE REMINDER INDICATOR CAME ON. I WENT TO AN AUTO PARTS STORE AND THEY RAN AN OBDII REPORT ON A BOSCH SCANNER. A B1448 OC (OCCUPANT CLASSIFICATION) - PASSENGER SENSOR MAT DEFECT CAME BACK. THIS IS THE SAME PROBLEM THAT THE 2006-2008 HYUNDAI SONATAS HAVE A RECALL ON. THE FRONT PASSENGER SEAT SENSOR, TO DETECT A CHILD SEAT OR ADULT IN THE…

07/25/2018 · Vehicle Speed Control
TL* THE CONTACT OWNS A 2004 HYUNDAI ELANTRA. WHILE DRIVING VARIOUS SPEEDS, THE THROTTLE POSITIONING SENSOR FAILED ON MORE THAN ONE OCCASION. UPON DECELERATION, THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE ACCELERATED RAPIDLY. IN ADDITION, THE CONTACT DESCRIBED THE BRAKE PEDAL AS HAVING A "DEAD SPOT", THUS TH…

06/25/2018 · Airbags
I HAVE CONTACTED CUSTOMER CARE AND WAS TOLD IT'S STANDARD TO REMOVE A FRONT SEAT AND GIVE THE CAR BACK UNTIL THEY GET PARTS FOR THE RECALL I FEEL THIS COULD CAUSE AIR BAG SYSTEMS NOT TO BE ACTIVE AND ALSO WITHOUT THE SEAT THE CARS ABILITY TO HOLD UP IN A CRASH IS REDUCED DUE TO MISSING COMPONENTS THAT PROVIDE SOME STRUCTURAL SUPPORT ALL I HAVE REQUESTED WAS…

02/15/2018 · Steering
I WAS DRIVING TO WORK AND SUDDENLY WHILE TRYING TO CHANGE LANE THE STEERING FREEZES ON ME, THIS HAPPEN NOW FOR THE SECOND TIME.

02/07/2018 · Brakes
THE ANTILOCK MACHINE IS LOCKING THE WHEELS SO MUCH THAT STOPS THE CAR COMPLETELY RIGHT IN THE MIDLE OF THE TRAFFIC AND THE TIRES SMELL LIKE BURNING TIRES. I HAD THE CAR TOWED TWICE. I AM SO AFRAID THAT THIS HAPPENS WHILE DRIVING IN THE HIGHWAY, THAT I DO NOT DRIVE THERE, ONLY THE STREETS.

01/01/2018 · Airbags
MY 2004 ELANTRA GLS HAS THE FOLLOWING PROBLEMS: 1 - THE PASSENGER AIRBAG OFF SIGN STAYS ON, EVEN WITH MY WIFE IN THE PASSENGER SEAT. 2 - THE AIRBAG LIGHT ON MY DASHBOARD IS ALWAYS ON, AND MY HORN IS NOT WORKING, FOR THE LAST TWO / THREE WEEKS (NOV / DEC 2017).