1991 Ford E-350 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-20. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. THE DUAL FUEL TANK SELECTOR VALVE MAY MALFUNCTION AND CAUSE AN OVERFILL CONDITION IN ONE OF THE FUEL TANKS, RESULTING IN AN OVERFLOW OF FUEL PAST THE FILLER CAP.
What could happen: THE OVERFLOW OF FUEL PAST THE FILLER CAP CAUSES A FUELLEAKAGE, WHICH CAN RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
The fix: REPLACE THE DUAL FUEL TANK SELECTOR VALVE.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1991 E-350.
- Book a repair at any authorized Ford dealer. Quote NHTSA campaign 91V146000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK:SELECTOR DEVICES
Summary: THE DUAL FUEL TANK SELECTOR VALVE MAY MALFUNCTION AND CAUSE AN OVERFILL CONDITION IN ONE OF THE FUEL TANKS, RESULTING IN AN OVERFLOW OF FUEL PAST THE FILLER CAP.
Consequence: THE OVERFLOW OF FUEL PAST THE FILLER CAP CAUSES A FUELLEAKAGE, WHICH CAN RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy: REPLACE THE DUAL FUEL TANK SELECTOR VALVE.
Notes: SYSTEM: FUEL TANK, AUXILLIARY.VEHICLE DESCRIPTION: VANS AND LIGHT TRUCKS WITH DUAL FUEL TANKS PRODUCED IN THEFOLLOWING PERIODS: F150, F250, AND F350 LIGHT TRUCKS BUILT BETWEEN FEBRUARY 28,1989 AND JULY, 1989; ECONOLINE BUILT BETWEEN FEBRUARY 28, 1989 ANDFEBRUARY 11, 1991.NOTE: FORD HAS AGREED TO RECALL THESE VEHICLES BUT PARTS ARE NOT YET AVAILABLE.PARTS WILL BE AVAILABLE IN DECEMBER 1991. YOU WILL RECEIVE A LETTER FROM FORDADVISING YOU WHEN TO SCHEDULE AN APPOINTMENT WITH YOUR DEALER TO HAVE THE RECALLWORK PERFORMED. IN THE MEAN TIME, YOU CAN TAKE THE FOLLOWING PRECAUTIONS:FILL EACH TANK TO ONLY 1/3 FULL.IF YOUR VEHICLE LEAKS FUEL OR IF YOU SMELL FUEL, STOP USING THE VEHICLE ANDCALL FORD AT (313) 446-4654 AND ADVISE THEM OF YOUR PROBLEM. REFER TO FORDSAFETY RECALL NUMBER 91S39. AN OPERATOR WILL TAKE YOUR NAME AND TELEPHONENUMBER. A FORD REPRESENTATIVE WILL CALL YOU BACK.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1991 Ford E-350 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Brakes (8), Hydraulic (8), Wheels / tires (2), Engine (2), Electrical system (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
07/09/2002 · Wheels / tires
THE RIGHT REAR TIRE, (KELLY-SPRINGFIELD LT235.85R16, LOAD RANGE E, DOT# PJOR BPKV 193) FAILED, CAUSING THE VEHICLE TO LEAVE THE ROADWAY AND OVER TURN SEVERAL TIMES. *JG. (ALABAMA UNIFORM TRAFFIC ACCIDENT REPORT)
10/03/2000 · Fuel system
FUEL PUMP FAILED CAUSING VEHICLE TO SHUT DOWN ON SEVERAL OCCASIONS. *SLC
09/30/2000 · Wheels / tires
THIS WAS THE INBOARD TIRE OF A PAIR ON THE RIGHT REAR OF THE VEHICLE. WHILE TRAVELING ON INTERSTATE 70 EASTBOUND OUT OF KANSAS CITY IT EXPLODED, SPLITTING THE STEEL BELTS CROSSWISE. EXCEPT FOR THE AREA OF THE BLOWOUT THE TIRE REMAINED RELATIVELY INTACT AND DID NOT SEPARATE. THE AMBIENT TEMPERATURE AT THE TIME WAS APPROXIMATELY 85 DEGREES F. NO ROAD HAZZ…
08/31/2000 · Engine
WHILE DRIVING IN THE MIDDLE OF HIGHWAY MOTOR WILL QUIT. CONSUMER MANAGES TO GET IT TO THE SIDE. *AK
10/14/1999 · Transmission / drivetrain
I HAVE HAD THE VEHICLE AND PARTS TO TWO DIFFERENT TRANSMISSION SHOPS AND BOTH HAVE TOLD ME THAT THIS NEVER SHOULD HAVE HAPPENED. BOTH THE DRUM AND SHAFT OF THE TORQUE CONVERTER HAVE STRIPPED. I STILL HAVE THE PARTS AND WOULD BE WILLING TO SHARE THEM WITH FORD IF A SETTLEMENT IS POSSIBLE.
10/28/1997 · Engine
ENGINE STALLS.
08/15/1997 · Electrical system · fire
ELECTRICAL FIRE, ORINATING IN THE GAS TANK, WIRES NOT BEING FUSED. *AK
05/28/1997 · Brakes
DEALER REFUSED RECALL REPAIR ON BRAKE LINE DUE TO VIN.