1991 Ford Taurus recalls & complaints

Component: VEHICLE SPEED CONTROL
Summary: VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Notes: OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN APRIL 7, 1997. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTRACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: STRUCTURE:FRAME AND MEMBERS
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Notes: NOTE: THIS RECALL CAMPAIGN SUPERCEDES RECALL CAMPAIGN 93V-106. OWNER NOTIFICATION IS EXPECTED TO BEGIN JANUARY 18, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SUSPENSION:FRONT:SHOCK ABSORBER
Summary: THE ARC WELDS ON THE SWAY BAR BRACKET, WHERE IT ATTACHES TO THE STRUT RESERVE TUBE, DID NOT FUSE PROPERLY.
Consequence: OVER TIME, A PORTION OF THE BRACKET CAN TEAR AWAY FROM THE STRUT, FALLING INTO AND PUNCTURING THE TIRE OR CAUSING DAMAGE TO THE WHEEL, WHICH COULD RESULT IN AN ACCIDENT.
Remedy: MONROE DEALERS WILL REPLACE THE STRUT FREE OF CHARGE.
Notes: EQUIPMENT DESCRIPTION: AFTERMARKET SHOCK ABSORBERS FOR 1986 - 1994 FORD TAURUS AND MERCURY SABLE PASSENGER CARS; PART 71780, 81780. IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT MONROE AT 1-800-521-6754. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: WHEELS
Summary: CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
Notes: SYSTEM: STRUCTURE: STORAGE COMPARTMENTS.VEHICLE DESCRIPTION: PASSENGER CARS (STATION WAGONS).NOTE: FORD WILL HAVE SUFFICIENT QUANTITIES OF THE NEW LATCH ASSEMBLIES AVAILABLETO BEGIN THE REPLACEMENT RECALL IN JULY, 1992. UNTIL THE LATCH ASSEMBLY ISREPLACED, FORD RECOMMENDS OWNERS LOCK THE STORAGE COMPARTMENT WHEN NOT IN USE.ALSO, FORD ADVISES THAT THE LATCH STRIKER CAN BE REMOVED TO DISABLE THE CURRENTLATCH UNTIL REVISED LATCH ASSEMBLIES ARE AVAILABLE.

Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
Summary: FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
Notes: SYSTEM: BRAKES.VEHICLE DESCRIPTION: PASSENGER VEHICLES SOLD OR REGISTERED IN THE FOLLOWING STATES: CT, IL, IN, ME, MA, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.

10/28/2012 · Vehicle Speed Control · crash
MY 1991 NON SHO FORD TAURUS WAS PARKED IN THE DRIVEWAY FOR 1 DAY. I WALKED OUT TO MY CAR IN THE EARLY MORNING TO TAKE IT TO WORK. I PUT THE KEY INTO THE IGNITION AND SHIFTED THE CAR INTO REVERSE. IT WAS AT THIS MOMENT, THAT THE CAR ACCELERATED AND I ENDED UP GOING IN REVERSE DOWN THE STREET WITHOUT BRAKES AT A VERY RAPID SPEED. I CAME TO A JARRING STOP AFTE…

10/15/2010 · Airbags
1991 FORD TAURUS. CONSUMER WRITES REGARDING A RECALL ON THE AIRBAG MODULE *TGW THE CONSUMER STATED THE AIR BAG MODULE FAILED FOR THE SECOND TIME. *JB

10/13/2010 · Transmission / drivetrain
TL*THE CONTACT OWNS A 1991 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE SUDDENLY STOPPED MOVING FORWARD AND WOULD NOT SHIFT INTO REVERSE GEAR. THE VEHICLE WAS TOWED TO HIS RESIDENCE. THE VEHICLE HAD NOT INSPECTED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 69,000.

05/11/2010 · Steering · fire
A POWER STEERING FLUID LEAK NEAR THE RACK RESULTED IN A FIRE, WHICH DESTROYED THE VEHICLE, AFTER ABOUT 30 MINUTES OF HIGHWAY DRIVING. *TR

03/24/2010 · Transmission / drivetrain
TL* THE CONTACT OWNS A 1991 FORD TAURUS. WHILE DRIVING AN APPROXIMATE SPEED OF 35 MPH, THE VEHICLE BEGAN TO SHAKE. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE INDEPENDENT MECHANIC REPLACED THE RADIATOR, BATTERY, MOTOR AND TRANSMISSION MOUNTS. THE CONTACT CONFIRMED THAT THE VEHICLE WAS REPAIRED PREVIOUSLY UNDER NHTSA CAMPAIGN ID NUMBERS: 98V323000…

03/09/2010 · Vehicle Speed Control · crash
TL*THE CONTACT OWNS A 1991 FORD TAURUS. THE CONTACT PARKED THE VEHICLE AND NOTICED THAT THE BUMPER WAS PARTIALLY OUT OF THE GARAGE. HE DROVE APPROXIMATELY 1 MPH, TO CLEAR THE GARAGE DOOR DID NOT TOUCH ACCELERATOR PEDAL, AND THE VEHICLE ACCELERATED AND CRASHED INTO A WALL. THE VEHICLE HAS NOT BEEN REPAIRED; HOWEVER, THERE WAS $5,000 IN DAMAGES TO VEHICLE.…

11/12/2007 · Visibility (wipers / glass)
THE BLOWER MOTOR IN MY 1991 FORD TAURUS IS STARTING TO GO OUT. THIS PROBLEM HAS BEEN HAPPENING FOR THE LAST WEEK AND A HALF. I WILL TURN THE HEAT ON HIGH IN THE MORNINGS TO WARM UP THE CAR AN WITHIN A 10-15 MINUTE TIME FRAME - THE MOTOR WILL EITHER STOP BLOWING COMPLETELY OR BARELY BLOW. I UNDERSTAND THERE IS AN EXISTING RECALL UNDER 03V087000 AND COMPLA…

08/15/2005 · Body / structure
I WAS ADVISED BY A MECHANIC RECENTLY THAT MY VEHICLE WAS UNSAFE. HE SHOWED ME THE REAR SUBFRAME BOLT THAT WAS DETERIORATED TO ABOUT HALF OF ITS ORIGINAL SIZE AND THAT THE SUBFRAME WAS RUSTED HEAVILY AND CRACKED COMPLETELY THROUGH. THIS WAS AFTER THE RECALL WAS DONE ON MY VEHICLE IN 1999 FOR NHTSA ARTICLE NO. 98V323000. SO THE WORK THAT WAS DONE TO KEEP T…