2006 Dodge Grand Caravan recalls & complaints

Component: VISIBILITY:GLASS, SIDE/REAR
Summary: CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
Remedy: SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Notes: THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
Summary: CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.
Consequence: IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.
Remedy: CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Notes: CHRYSLER'S CAMPAIGN NUMBER IS J38. CHRYSLER HAS NOT DECIDED THAT THIS IS A DEFECT RELATED TO MOTOR VEHICLE SAFETY. HOWEVER, CHRYSLER HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE AT NO COST.

Component: VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
Summary: ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.
Consequence: DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Notes: DAIMLERCHRYSLER RECALL NO. F10. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: SEATS
Summary: DRIVING SPECIALTIES LTD IS RECALLING 2 MODEL YEAR 2006 AND 2007 CONVERSION VANS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: DRIVING SPECIALTIES WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 28, 2010. OWNERS MAY CONTACT DRIVING SPECIALTIES AT 1-707-553-1515.
Notes: THIS RECALL ONLY PERTAINS TO VEHICLES ALTERED BY DRIVING SPECIALTIES AND HAS NO RELATION TO ANY VEHICLES MANUFACTURED BY CHRYSLER. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

11/28/2025 · Engine
The contact owns a 2006 Dodge Grand Caravan. The contact stated that when the vehicle was purchased in 2010, the vehicle was missing the EGR (Exhaust Gas Recirculation) valve. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle idled roug…

05/14/2025 · Transmission / drivetrain
The contact owns a 2006 Dodge Grand Caravan. The contact stated while driving 5-10 MPH and pulling out of the parking lot, the vehicle stalled. The contact was able to coast into a gas station. The contact stated that the engine was running, but the vehicle failed to respond while depressing the accelerator pedal. The vehicle was towed to the residence. The…

07/20/2024 · Brakes
My complaint involves more than one incident...it is the braking system on this vehicle. One incident was in Panama City Beach, Florida. My entire braking system locked up and I had numerous items replaced. Another more recent incident happened in Alabama. My left front brake heated up to the point it smelled like the vehicle was on fire. I have had se…

09/21/2023 · Airbags
The contact owns a 2006 Dodge Grand Caravan. The contact stated that on several occasions, the air bag warning light illuminated for two minutes and then disappeared. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 146,032.

06/19/2021 · Lights
The headlights and taillights come on randomly throughout the day and night while the car is parked and off. The warning dings for accidentally leaving your lights on happens every time you open the doors even though the lights are off. This has been going on since we got the vehicle.

01/16/2020 · Lights
LIGHTS GO OUT WHEN THE RAIN GETS UP UNDER THE CAR FROM SPLASHING ON THE ROAD. YOU HAVE TO PULL OVER TO THE SIDE OF THE ROAD, TURN IT OFF AND TURN IT BACK ON SEVERAL TIMES AND IT STAYS ON FOR A SHORT TIME. PROCEDURE IS REPEATED AGAIN. ONLY IN RAINY WEATHER AND OREGON GETS A LOT OF SPORADIC RAIN. ALSO, THE IGNITION TENDS TO TURN THE AIRBAG LIGHTS ON AND OFF W…

11/14/2019 · Engine
TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING 45 MPH, THE OIL PRESSURE AND AN UNKNOWN WARNING INDICATOR ILLUMINATED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. ON NOVEMBER 9, 2019, WHILE DRIVING 55 MPH, WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FA…

11/10/2019 · Unknown Or Other
SLIDING DOOR LOCK ACTUATOR FROZE UP.THIS RENDERSTHE SLIDING DOOR COMPLETELY INOPERABLE.IF THAT DOOR WAS NEEDED FOREGRESS,IT WOULDNT BE AVAILABLE!!