1994 BMW 525i recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Vehicle Speed Control
What's wrong, in plain English: A vehicle part that may fail. THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE…
What could happen: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
The fix: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 525I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 97V131000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VEHICLE SPEED CONTROL
Summary: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN BY THE END OF OCTOBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
2. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
What could happen: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The fix: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 525I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 96V111000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Summary: THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Notes: SYSTEM: BRAKES; HYDRAULIC; SWITCH; BRAKE LIGHT. VEHICLE DESCRIPTION: PASSENGER VEHICLES. OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN AUGUST 5, 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
3. Latches / locks
What's wrong, in plain English: Doors, hood or trunk may open unexpectedly. THE DOUBLE-LOCK FEATURE CAN ENGAGE WITH OCCUPANTS AND THE DOOR/IGNITION KEY INSIDE THE VEHICLE.
What could happen: THE OCCUPANTS OF THE VEHICLE WOULD BE UNABLE TO EXIT EITHER FROM THE DOORS OR FROM THE WINDOWS OF THE VEHICLE. DRIVE-AWAY PROTECTION WOULD PREVENT THE ENGINE FROM STARTING.
The fix: DEALERS WILL REPLACE THE GENERAL CONTROL MODULE WITH ONE CONTAINING THE REVISED SOFTWARE TO PERMIT WINDOW OPENING WITH THE DOUBLE-LOCK ENGAGED AND KEY IN THE IGNITION.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 525I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 94V219000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Summary: THE DOUBLE-LOCK FEATURE CAN ENGAGE WITH OCCUPANTS AND THE DOOR/IGNITION KEY INSIDE THE VEHICLE.
Consequence: THE OCCUPANTS OF THE VEHICLE WOULD BE UNABLE TO EXIT EITHER FROM THE DOORS OR FROM THE WINDOWS OF THE VEHICLE. DRIVE-AWAY PROTECTION WOULD PREVENT THE ENGINE FROM STARTING.
Remedy: DEALERS WILL REPLACE THE GENERAL CONTROL MODULE WITH ONE CONTAINING THE REVISED SOFTWARE TO PERMIT WINDOW OPENING WITH THE DOUBLE-LOCK ENGAGED AND KEY IN THE IGNITION.
Notes: SYSTEM: STRUCTURE; DOOR ASSEMBLY; LATCHES AND LOCKS. VEHICLE DESCRIPTION: PASSENGER VEHICLES. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT BMW AT 1-800-831-1117. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
4. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
What could happen: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
The fix: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 525I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 98V178000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE AND ENGINE COOLING:COOLING SYSTEM
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
Notes: OWNER NOTIFICATION BEGAN MARCH 31, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Engine (3), Transmission / drivetrain (1), Latches / locks (1), Visibility (wipers / glass) (1), Equipment (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
12/03/2008 · Transmission / drivetrain
MY TRANSMISSION WENT OUT IN MY 1994 BMW 525I. THIS HAS BEEN REPORTEDLY HAPPENING TO MANY OF US. THE FAILURE WAS IN THE REVERSE GEAR FIRST, THEN THE FIRST TWO FORWARD GEARS. *TR
06/03/2002 · Latches / locks
CONSUMER'S VEHICLE WAS HAVING THE SAME DOOR LOCK/LATCH PROBLEM AS STATED IN RECALL 94V219000. BUT THIS VEHICLE WAS NOT INCLUDED IN RECALL DUE TO VIN. *AK
06/03/2002 · Engine
CONSUMER HAS SAME PROBLEM WITH COOLANT SYSTEM AS STATED IN RECALL 98V178000. BUT, THIS VEHICLE WAS NOT INCLUDED IN RECALL DUE TO VIN. *AK
10/05/1999 · Engine
RADIATOR BLEW OUT WHILE DRIVING AT 55 MPH, CAUSING VEHICLE TO OVERHEAT. ALSO, HEATER CORE CRACKED. *AK
09/28/1999 · Engine
HEAD GASKET WAS REPLACED UNDER WARRANTY 3/31/98 DUE TO OIL LEAK. FAILED AGAIN ON 4/28/99 AT 55900 MILES. WHITE EXHAUST SMOKE AND COOLANT DROP OG 35 MM IN 2438 MILES. AIR CONDITIONER COMPRESSOR NOISY AND VIBRATES STEERING WHEEL AND DOES NOT COOL AT IDLE. COMPLAINT UNDER WARRANTY ON 3/31/98 NOT FIXED. REPLACED IDLER PULLEY ONLY. GETTING WORSE ON 4/30/99 AT 5…
06/11/1998 · Vehicle Speed Control
AFTER HAVING RECALL REPAIR WORK DONE LAST WEEK VEHICLE IS STILL EXPERIENCING SAME PROBLEM, THE THROTTLE WILL REMAIN OPEN, WHILE DRIVING VEHICLE. RECALL # 97V131000. *AK
07/28/1997 · Electrical system
COMPUTER COMMAND CONTROL MODULE FAILED, LOCKING CONSUMER IN VEHICLE.
02/03/1997 · Steering
SECURITY SYSTEM ENGAGED WHILE OCCUPANTS INSIDE, OCCUPANTS TRAPPED INSIDE.