1995 BMW 525i recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
3 safety recalls, most serious first
1. Vehicle Speed Control
What's wrong, in plain English: A vehicle part that may fail. THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE…
What could happen: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
The fix: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 525I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 97V131000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VEHICLE SPEED CONTROL
Summary: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN BY THE END OF OCTOBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
2. Latches / locks
What's wrong, in plain English: Doors, hood or trunk may open unexpectedly. THE DOUBLE-LOCK FEATURE CAN ENGAGE WITH OCCUPANTS AND THE DOOR/IGNITION KEY INSIDE THE VEHICLE.
What could happen: THE OCCUPANTS OF THE VEHICLE WOULD BE UNABLE TO EXIT EITHER FROM THE DOORS OR FROM THE WINDOWS OF THE VEHICLE. DRIVE-AWAY PROTECTION WOULD PREVENT THE ENGINE FROM STARTING.
The fix: DEALERS WILL REPLACE THE GENERAL CONTROL MODULE WITH ONE CONTAINING THE REVISED SOFTWARE TO PERMIT WINDOW OPENING WITH THE DOUBLE-LOCK ENGAGED AND KEY IN THE IGNITION.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 525I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 94V219000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Summary: THE DOUBLE-LOCK FEATURE CAN ENGAGE WITH OCCUPANTS AND THE DOOR/IGNITION KEY INSIDE THE VEHICLE.
Consequence: THE OCCUPANTS OF THE VEHICLE WOULD BE UNABLE TO EXIT EITHER FROM THE DOORS OR FROM THE WINDOWS OF THE VEHICLE. DRIVE-AWAY PROTECTION WOULD PREVENT THE ENGINE FROM STARTING.
Remedy: DEALERS WILL REPLACE THE GENERAL CONTROL MODULE WITH ONE CONTAINING THE REVISED SOFTWARE TO PERMIT WINDOW OPENING WITH THE DOUBLE-LOCK ENGAGED AND KEY IN THE IGNITION.
Notes: SYSTEM: STRUCTURE; DOOR ASSEMBLY; LATCHES AND LOCKS. VEHICLE DESCRIPTION: PASSENGER VEHICLES. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT BMW AT 1-800-831-1117. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
3. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
What could happen: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
The fix: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1995 525I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 98V178000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE AND ENGINE COOLING:COOLING SYSTEM
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
Notes: OWNER NOTIFICATION BEGAN MARCH 31, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1995 BMW 525i owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (5), Latches / locks (5), Engine (4), Seat belts (4), Transmission / drivetrain (3).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
12/23/2022 · Electrical system
RECAL 94V219000: Double-lock Feature GCM Revised. "The double-lock feature can engage with occupants and the door/ignition key inside of the vehicle. The occupants of the vehicle would be unable to exit either from the doors or from the windows of the vehicle." NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND T…
05/01/2012 · Latches / locks
TL* THE CONTACT OWNS A 1995 BMW 525I. WHILE PARKED WITH THE KEY OUT OF THE IGNITION, THE OCCUPANT IN THE VEHICLE WAS UNABLE TO OPEN ANY OF THE DOORS OR WINDOWS MANUALLY. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 94V219000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE A…
06/29/2010 · Latches / locks
TL* THE CONTACT OWNS A 1995 BMW 525I. AFTER SITTING IDLE IN THE VEHICLE, THE CONTACT ATTEMPTED TO EXIT BUT WAS LOCKED IN THE VEHICLE FOR OVER TEN MINUTES. THE CONTACT REFERENCED NHTSA RECALL CAMPAIGN ID NUMBER: 94V219000 (LATCHES/LOCKS/LINKAGES: DOORS: LATCH) HOWEVER THE DEALER ADVISED HER VIN WAS NOT INCLUDED IN THE RECALL. ANY REPAIRS WOULD BE AT THE EXP…
02/18/2010 · Latches / locks
OWNER OF 1995 BMW 525 WAS UNABLE TO EXIT CAR .WINDOWS WOULD NOT OPEN WITH KEY ON NOR DID SUNROOF OPEN. THE CAR WOULD NOT START. SOUTH BAY DEALERSHIP REFUSED TO HONOR RECALL NUMBER 94V219000 AS SO DID BMW HEADQUARTERS. *TR
09/09/2008 · Latches / locks
ON A HOT AFTERNOON IN SACRAMENTO, WE STOPPED IN A PARKING LOT AND SHUT OFF THE CAR PREPARING TO EXIT. THE WINDOWS OF THE BMW WERE UP AND WE WERE NOT ABLE TO OPEN THE DOORS. THE ENGINE WOULD NOT START AND WE WERE TRAPPED IN THE HOT CAR. FORTUNATELY WE HAD A CAR PHONE AND CALLED 911 FOR HELP. AFTER A FRIGHTENING HALF HOUR TRAPPED IN THE HOT LOCKED CAR…
08/20/2007 · Latches / locks
TL*THE CONTACT OWNS A 1995 BMW 525I. THE CONTACT STATED THAT THE DRIVER SIDE FRONT DOOR FAILED TO UNLOCK AND THE DRIVER SIDE WINDOW FELL DOWN INTO THE VEHICLE. THE PASSENGER SIDE AND REAR DOORS WILL OPEN, BUT SHE MUST OPEN THEM QUICKLY. THE CONTACT HAS BEEN LOCKED IN THE VEHICLE ONCE. THE DEALER WAS NOTIFIED. NHTSA RECALL NUMBER 94V219000 (LATCHES/LOCK…
08/22/2006 · Engine · fire
1995 BMW 525I CAUGHT ON FIRE WHILE DRIVING. *TS THE FIRE STARTED UNDER THE HOOD. THE ENTIRE FRONT END OF THE VEHICLE WAS DAMAGED. THE CAUSE OF THE FIRE WAS NOT DETERMINED. THERE WERE NO INJURIES *NM
04/07/2005 · Transmission / drivetrain
TRANSMISSION SLIPPING. I HAVE A 1995 525 BMW WITH 112000 MILES. THE TRANSMISSION INSTANTLY ONE DAY SLIPPED AND THE INDICATOR LIGHT WENT ON TO SEE MY DEALER. I DID AND WAS TOLD THE TRANSMISSIONS ON BMW'S MUST BE REPLACED, THEY CANNOT BE FIXED OR REPAIRED. I CALLED BMW AND SPOKE TO A TIM IN CUSTOMER SERVICE. I ASKED FOR SOME TYPE OF WARRANTY, AND WAS GIVEN A…