1994 BMW 318i recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
2 safety recalls, most serious first
1. Vehicle Speed Control
What's wrong, in plain English: A vehicle part that may fail. THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE…
What could happen: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
The fix: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 318I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 97V131000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VEHICLE SPEED CONTROL
Summary: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN BY THE END OF OCTOBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
2. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
What could happen: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
The fix: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 318I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 98V178000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE AND ENGINE COOLING:COOLING SYSTEM
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
Notes: OWNER NOTIFICATION BEGAN MARCH 31, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Engine (5), Electrical system (3), Transmission / drivetrain (2), Fuel system (2), Gasoline (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
12/19/2012 · Transmission / drivetrain · crash
MY VEHICLE WAS PARKED ON A SLIGHT HILL AND THE HAND BRAKE WAS PULLED UP TO ITS FULL CAPACITY. MY BROTHER SAT IN THE CAR AND SMOKED A CIGARETTE BEFORE GOING TO HIS APPOINTMENT. AFTER HE RETURNED FROM HIS APPOINTMENT, THE VEHICLE COULD NOT BE FOUND. AFTER LOOKING AROUND, HE REALIZED THAT THE VEHICLE HAD ROLLED DOWN THE HILL, ACROSS A BUSY TWO-WAY MAIN ROAD…
08/12/2005 · Engine
DT: THE CONTACT STATED VEHICLE OVERHEATED RANDOMLY. THE ENGINE HEAD WAS REPLACED TWICE AND NEEDED TO BE REPLACED AGAIN. THE REPAIRS WERE COSTLY. HOWEVER, THE DEALERSHIP REIMBURSED THE CONSUMER FOR ONE REPAIR, BUT WILL NOT DO IT AGAIN. CONSUMER STATE WHILE DRIVING ON THE HIGHWAY VEHICLE OVERHEATED. THE ENTIRE HEAD OF THE ENGINE HAD TO BE REPLACED…
05/14/2002 · Fuel system
FUEL LEAKAGES FROM THE UPPER RETURN LINES. DEALER MAKING REPAIRS. *AK DEALER CLAIMS IT WAS NEXT TO THE STARTER. ALSO CLAIMS IT WAS FIXED, HOWEVER IT IS NOT. *JG
03/04/2002 · Vehicle Speed Control
INITIAL THROTTLE RECALL (NHTSE #97V131000) PERFORMED 5-13-98. PROBLEMS RELATING TO CRUISE CONTROL/BRAKE LIGHTS CONTINUE. (PLEASE NOTE: THERE ARE IRREGULARITIES IN SEVERAL FIELDS OF THE QUESTIONAIRE THAT SHOW UP INCORRECTLY ON THE FINAL CHART.)
09/02/2001 · Body / structure
INTERIOR DOOR PANEL ASSEMBLIES ON 3 (THREE) SECTIONS OF THE VEHICLE HAVE DETACHED - IN THE EVENT OF ACCIDENT, PASSENGERS MAY NOT BE ABLE TO ESCAPE! ALSO, FLAWED DOOR PANEL ASSEMBLIES MAKE ENTERY/EGRESS FROM VEHICLE DIFFICULT/DANGEROUS.
08/01/2001 · Engine
TEMPERATURE GUAGE RISES AND A LARGE AMOUNT OF COOLANT SPILL ENGINE OVERHEATS ENGINE STALLS I REALLY DON'T EXPECT THIS ON A BMW WHY DON'T HELP US WITH THE PROBLEM I'M REALLY DISAPOINTED THEY JUST IGNORE THE PROBLEM.
06/08/2001 · Transmission / drivetrain
WOULD BE DRIVING AND VEHICLE FAILED TO SHIFT FROM FIRST INTO 2ND GEAR. WOULD GET HUNG UP IN FIRST. THEN, IT WOULD SUDDENLY JERK AND SHIFT INTO 2ND. TAKEN TO DEALERSHIP, MECHANIC INDICATED PROBLEM OF SHIFTING WAS REPAIRABLE.*AK
04/30/2001 · Engine
WHILE DRIVING ON EXPRESSWAY, VEHICLE BEGAN TO OVERHEAT AND RED LIGHT CAME ON, CONSUMER HAD VEHICLE INSPECTED AND WAS ADVISED THAT HEAD GASKET CONTAINED A CRACK WHICH CAUSED COOLANT TO LEAK AND CAUSED SEVERE DAMAGE TO THE ENGINE HEAD, CONSUMER WAS ALSO ADVISED BY REPUTABLE BMW DEALERS THAT VEHICLE WAS DESIGNED WITH A FAULTY PART CALLED THE PROFILE GASKET AND…