2022 Volvo Xc90 T5 Awd recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.
What could happen: The vehicle may lose drive power as the high voltage battery is depleted, increasing the risk of a crash.
The fix: Dealers will update the ECM software, free of charge. Owner notification letters are expected to be mailed December 8, 2022. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10198.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2022 XC90 T5 AWD.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 22V793000 (manufacturer code R10198).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
Summary: Volvo Car USA, LLC (Volvo Car) is recalling certain 2022-2023 S60, V60, S90L, XC60, and XC90 vehicles. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.
Consequence: The vehicle may lose drive power as the high voltage battery is depleted, increasing the risk of a crash.
Remedy: Dealers will update the ECM software, free of charge. Owner notification letters are expected to be mailed December 8, 2022. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10198.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
2. Steering
What's wrong, in plain English: If steering fails you can lose control of the car. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
What could happen: A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
The fix: Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2022 XC90 T5 AWD.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 23V001000 (manufacturer code R10213).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STEERING
Summary: Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Consequence: A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
Remedy: Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
3. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
What could happen: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.
The fix: Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2022 XC90 T5 AWD.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 23V827000 (manufacturer code R10259).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:CRITICAL FASTENERS
Summary: Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Consequence: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.
Remedy: Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
4. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
What could happen: A short circuit in a high-voltage battery increases the risk of a fire.
The fix: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mai…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2022 XC90 T5 AWD.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 25V179000 (manufacturer code R10312).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:SOFTWARE
Summary: Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2022 Volvo Xc90 T5 Awd owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (13), Fuel system (9), Engine (7), Unknown Or Other (5), Lane Departure (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
07/17/2026 · Unknown Or Other
This is my 2nd Volvo xc90. Both models have turbo issues that is costly repairs. Volvo dealership also stated that turbo repairs usually are an issue in Volvo. My first Volvo was 2016 which had a turbo issue. Now my 2022 is now in shop due to turbo and oil spills on inside. There should be a recall.
05/04/2026 · Lane Departure
The electrical/infotainment display failure causes the factory rearview camera image not to display when the vehicle is shifted into reverse. The center infotainment display on my 2022 Volvo XC90 intermittently goes completely black and remains inoperable for days at a time. When the screen is black, the factory rearview camera image does not display when…
02/25/2026 · Electrical system
In the middle of a cold snowstorm the screen froze and started glitching. As I was trying to change the drive mode to all wheel drive the ESC off button triggered and ESC stayed off without AWD mode and screen was unresponsive. Had to pull over and turn car off and back on for screen to reset.
10/29/2025 · Unknown Or Other
There is a flaw in Volvo sunroof drains. There are class action lawsuits because of this. 6 months after purchasing my car, there was a leak into my car due to a clogged sunroof drains causing damage to electronics and potentially to computers within the car. I fixed it at a quote of over $2k. Volvo refused to cover it under my warranty. Now, 6 months…
09/22/2025 · Electrical system
My car is a 2022 Volvo hybrid T8, 6-passenger XC90. I purchased the SUV in August of 2023 as a "certified pre-owned" vehicle with only 17,923 miles on it at the time of purchase. This SUV has been fine until within the last two to three months (July-Sept. 2025). Now, in Sept. of 2025, my SUV only has 30,795 miles and we have had it serviced regularly, as…
07/21/2025 · Unknown Or Other
I park my Volvo in my driveway which has a blind exit to a pedestrian sidewalk. When I start the car and put it in D or B mode, it does not make any sound. This happens in any of the vehicle modes including "Pure" electric where the ICE is not engaged unless the battery runs out. There is no way for oncoming pedestrians to hear the vehicle or to understand…
06/20/2025 · Electrical system
The contact owns a 2022 Volvo XC90. The contact received notification of NHTSA Campaign Number: 25V179000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made…
09/20/2024 · Airbags
I received an SRS airbag, service urgent, drive to workshop warning. I took the car in six times the first two times they said it was a software update and they failed to update the software the third time they updated the software. It didn’t work the fourth time they said it was the passenger seat and the scale wasn’t working or connecting so it was throwi…