2016 Volvo Vnl recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
6 safety recalls, most serious first
1. Steering
What's wrong, in plain English: If steering fails you can lose control of the car. The trucks may have been manufactured without a roll pin on the steering shafts. If the roll pin is missing, the lower steering shaft may disconnect from the junction block. Also, the bolt connecting the upper steering shaft to the lower steering shaft may not have been properly tightened. Either condition can lead to separation of the steering shaft.
What could happen: Separation of the steering shaft will result in complete loss of steering which may lead to a vehicle crash.
The fix: Volvo is strongly recommending that the affected vehicles not be driven until the interim remedy is applied. An interim notice was sent to Volvo owners on March 16, 2016, and an interim repair is available now. A second notice was mailed on May 13, 2016. The final remedy is now available. Both remedies are free of…
What to do
- Do not drive this vehicle until the recall repair is done. The manufacturer has told owners to park it.
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 VNL.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 16V097000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-877-800-4945.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STEERING
Summary: Volvo Trucks North America (Volvo) is recalling certain model year 2016-2017 VNL, VNX, and VNM trucks manufactured from May 11, 2015, through April 18, 2016. The trucks may have been manufactured without a roll pin on the steering shafts. If the roll pin is missing, the lower steering shaft may disconnect from the junction block. Also, the bolt connecting the upper steering shaft to the lower steering shaft may not have been properly tightened. Either condition can lead to separation of the steering shaft.
Consequence: Separation of the steering shaft will result in complete loss of steering which may lead to a vehicle crash.
Remedy: Volvo is strongly recommending that the affected vehicles not be driven until the interim remedy is applied. An interim notice was sent to Volvo owners on March 16, 2016, and an interim repair is available now. A second notice was mailed on May 13, 2016. The final remedy is now available. Both remedies are free of charge. Owners may contact Volvo customer service at 1-877-800-4945 opt #1. Volvo's recall numbers for this campaign are RVXX1602 and RVXX1603. This recall supersedes safety recall 15V-786.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
2. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.
What could happen: If the fuel line bursts, fuel may leak onto the road resulting in a roadway hazard for other motorists. The engine may also stall without warning, resulting in the vehicle's inability to restart, increasing the risk of a crash.
The fix: Cummins will notify owners, and dealers will replace the single screen filter banjo bolt will be replaced with a dual screen filter banjo bolt, free of charge. The recall began November 21, 2018. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1802.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 VNL.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 18V668000 (manufacturer code RVXX1802).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-528-6586.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Summary: Volvo Trucks North America (Volvo) is recalling certain 2016-2019 Volvo VNL trucks equipped with Cummins ISX15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.
Consequence: If the fuel line bursts, fuel may leak onto the road resulting in a roadway hazard for other motorists. The engine may also stall without warning, resulting in the vehicle's inability to restart, increasing the risk of a crash.
Remedy: Cummins will notify owners, and dealers will replace the single screen filter banjo bolt will be replaced with a dual screen filter banjo bolt, free of charge. The recall began November 21, 2018. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1802.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
3. Steering
What's wrong, in plain English: If steering fails you can lose control of the car. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
What could happen: If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering, increasing the risk of a crash.
The fix: Volvo will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on October 17, 2017. O…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 VNL.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 17V536000 (manufacturer code RVXX1702).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-528-6586.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STEERING
Summary: Volvo Trucks North America (Volvo) is recalling certain 2016 Volvo VNL and VNM trucks equipped with certain Dana Spicer D-Series and E-Series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence: If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering, increasing the risk of a crash.
Remedy: Volvo will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on October 17, 2017. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1702.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
4. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.
What could happen: If the brake system becomes contaminated, braking performance could be affected, increasing the risk of a crash.
The fix: Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1608.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 VNL.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 16V928000 (manufacturer code RVXX1608).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-528-6586.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SERVICE BRAKES, AIR
Summary: Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.
Consequence: If the brake system becomes contaminated, braking performance could be affected, increasing the risk of a crash.
Remedy: Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1608.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
5. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. The affected actuators may have an incomplete attachment of the internal rubber diaphragm to the actuation mechanism of the parking brake section of the Life Seal actuator.
What could happen: If the diaphragm is not completely attached, there may be internal leakage from the service section past the diaphragm, potentially trapping air pressure in the parking brake section. This air pressure in turn, if not vented, may prevent full release of the actuator unit, and may induce brake drag…
The fix: Volvo will notify owners, and dealers will inspect the brake actuator and replace, as necessary, free of charge. The recall began March 20, 2015. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1501.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 VNL.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 15V026000 (manufacturer code RVXX1501).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-528-6586.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: PARKING BRAKE:DRIVELINE:HYDRAULIC:ACTUATOR
Summary: Volvo Trucks North America (Volvo) is recalling certain model year 2015 and 2016 VNX and VNL trucks manufactured from May 20, 2014, through March 6, 2015, equipped with certain Haldex Life Seal Type 30/30 Long Stroke Air Brake Actuators manufactured January 9, 2014, to October 28, 2014. The affected actuators may have an incomplete attachment of the internal rubber diaphragm to the actuation mechanism of the parking brake section of the Life Seal actuator.
Consequence: If the diaphragm is not completely attached, there may be internal leakage from the service section past the diaphragm, potentially trapping air pressure in the parking brake section. This air pressure in turn, if not vented, may prevent full release of the actuator unit, and may induce brake drag and may result in overheated wheelend service brakes, increasing the risk of a fire.
Remedy: Volvo will notify owners, and dealers will inspect the brake actuator and replace, as necessary, free of charge. The recall began March 20, 2015. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1501.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
6. Suspension
What's wrong, in plain English: Parts can break and cause loss of control. The affected vehicles are equipped with USK non-greasable drag links that may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint.
What could happen: Failure of the ball joint may cause separation of the socket and a complete loss of steering, increasing the risk of a crash.
The fix: Volvo will notify owners, and dealers will replace the drag links, free of charge. The recall began on April 21, 2016. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1601. Note: This recall is an expansion of a previous recall 15V-651.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2016 VNL.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 16V095000 (manufacturer code RVXX1601).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-528-6586.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
Summary: Volvo Trucks North America (Volvo) is recalling certain model year 2009-2010 VT trucks manufactured from April 9, 2008, through September 24, 2009, and certain 2016 model VNL and VNM trucks manufactured from January 2, 2015, through to November 6, 2015. The affected vehicles are equipped with USK non-greasable drag links that may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint.
Consequence: Failure of the ball joint may cause separation of the socket and a complete loss of steering, increasing the risk of a crash.
Remedy: Volvo will notify owners, and dealers will replace the drag links, free of charge. The recall began on April 21, 2016. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1601. Note: This recall is an expansion of a previous recall 15V-651.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2016 Volvo Vnl owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Transmission / drivetrain (7), Suspension (2), Brakes (2), Wheels / tires (1), Unknown Or Other (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
06/18/2019 · Transmission / drivetrain
TL* THE CONTACT OWNS A 2016 VOLVO VNL630. THE CONTACT STATED THAT THE VEHICLE ARRIVED FROM THE MANUFACTURER WITH A REAR DRIVESHAFT THAT WAS NOT CALIBRATED. THE DRIVESHAFT WAS THREE TIMES OVER THE MAXIMUM SPECIFICATIONS WHERE THE TRANSMISSION AND DRIVESHAFT WERE ATTACHED. THE FAILURE IN MANUFACTURING CAUSED A CONSIDERABLE AMOUNT OF VIBRATION WHILE THE VEHICL…
03/31/2019 · Transmission / drivetrain · crash
FRONT WHEELS LOOSE FROM FACTOR AND DEALER DIDN'T CHECK, TIRES PSI 1/2 WHAT SHOULD BEEN , DRIVE SHAFT OUT OF PHASE . DAMAGE THE TRUCK MORE .I KNOW OF ABOUT 20 OF THESE TRUCK WITH THE DRIVE SHAFT PROBLEM . DEALER AND FACTOR WONT FIX/ THIS IS NOT SAFE
03/28/2019 · Transmission / drivetrain · crash
VOLVO AND MACK DRIVE SHAFT OUT OF PHASE. I SHOWED MY DR. MY VIDEO OF MY TRUCK SHAKING. HE SAID YOU MIT AS WILL BE D W I
08/22/2018 · Transmission / drivetrain
TL* THE CONTACT OWNS A 2016 VOLVO VNL SEMI-TRUCK. WHILE DRIVING VARIOUS LOW AND HIGH SPEEDS, THE VEHICLE VIBRATED. A SERIES OF INDEPENDENT MECHANICS CONFIRMED THAT THE DRIVESHAFT WAS LOOSE WITHIN THE TRANSMISSION. VOMAC SALES AND SERVICE MACK (5556 EAST MARGARET DRIVE, TERRE HAUTE, INDIANA 47803, (812) 233-6406) WAS CONTACTED, BUT THE VEHICLE WAS NOT DIAGNO…
01/01/2018 · Transmission / drivetrain
MY STUPID DEALER CIT TRUCKS COULD NOT FIND Y MY TRUCK WAS SHAKING SO THEY PLAYED WITH TRANSMISSION PROGRAMING ITS AN I SHIFT NO CLUTCH PEDDLE . STONINGTON IL. GOT FUEL AT F.S. COMING BACK CROSS RAIL ROAD TRACKS AND TRIED TO STOP FOR RT 48 . THE CLUTCH WOULD NOT RELEASE .THIS THE 4 TIME .
01/01/2018 · Transmission / drivetrain
NEW VOLVO TRUCK MID MARCH 2016 IT HAD A SHAKE THAT GOT WORSE . MY DEALER CIT TRUCKS WAS TO STUPID FIND THE PROBLEM. ANTHER DEALER LOOK AT IT. THE REAR DRIVE SHAFT WAS OUT OF PHASE BUT HOW AFTER ALMOST 80000 MILES THE REAR ENDS ARE GOING OUT . MY TRUCK IS NOT THE ONLY ONE OUT THERE . VIDEOS CAN BE SEEN AT YOU TUBE- VOLVO SHAKES AND VOLVO TRUCK SHAKES
07/16/2017 · Suspension
VOLVO AND MACK TRUCKS DRIVE SHAFTS OUT OF PHASE. MAKING IT SHAKE AND EAT UP TIRES AND WEAR TRUCK OUT SHOULD BE RECALLED
08/28/2016 · Suspension
MY NEW VOLVO TRUCK SHAKES AND STARTING TO HOP R JUMP 30K MILES HTTPS://YOUTU.BE/EU119G9VYCU