2006 Volvo V50 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
3 safety recalls, most serious first
1. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires.
What could happen: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
The fix: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2006 V50.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 10V566000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
Summary: VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Notes: VOLVO SAFETY RECALL NO. R231. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
2. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH T5 TURBO ENGINES, THE POLYAMIDE TUBE IN THE FUEL LINE IS SENSITIVE TO THE EXTREME TEMPERATURES THAT MAY OCCUR IN THE AREA WHERE THE TURBO/EXHAUST MANIFOLD IS LOCATED.
What could happen: THIS MAY POTENTIALLY RESULT IN FUEL LINE LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
The fix: DEALERS WILL CHANGE THE FUEL LINE MATERIAL TO TEFLON FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2006 V50.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 06V137000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE
Summary: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH T5 TURBO ENGINES, THE POLYAMIDE TUBE IN THE FUEL LINE IS SENSITIVE TO THE EXTREME TEMPERATURES THAT MAY OCCUR IN THE AREA WHERE THE TURBO/EXHAUST MANIFOLD IS LOCATED.
Consequence: THIS MAY POTENTIALLY RESULT IN FUEL LINE LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL CHANGE THE FUEL LINE MATERIAL TO TEFLON FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Notes: VOLVO RECALL NO. R158. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. ON CERTAIN VEHICLES SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, REOCCURRING, LONG-TERM EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS SUCH AS SALTY-WET CONDITIONS, IT IS…
What could happen: IF THIS OCCURS, THE CHECK ENGINE LIGHT MAY ILLUMINATE. IN SOME CASES, THE VEHICLE MAY FAIL TO START OR MAY STALL, INCREASING THE RISK OF A CRASH.
The fix: DEALERS WILL REPLACE THE PEM AND INSTALL IT IN A NEW LOCATION TO PREVENT CORROSION. THE RECALL BEGAN ON FEBRUARY 20, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2006 V50.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 08V033000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: ON CERTAIN VEHICLES SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, REOCCURRING, LONG-TERM EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS SUCH AS SALTY-WET CONDITIONS, IT IS POSSIBLE FOR THE PUMP ELECTRONIC MODULE (PEM) TO BECOME CORRODED INTERNALLY. THIS CAN CAUSE A FAULTY SIGNAL TO THE FUEL PUMP, RESULTING IN LOW OR NO FUEL PRESSURE TO THE ENGINE.
Consequence: IF THIS OCCURS, THE CHECK ENGINE LIGHT MAY ILLUMINATE. IN SOME CASES, THE VEHICLE MAY FAIL TO START OR MAY STALL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PEM AND INSTALL IT IN A NEW LOCATION TO PREVENT CORROSION. THE RECALL BEGAN ON FEBRUARY 20, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Notes: VOLVO RECALL NO. 190. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2006 Volvo V50 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (4), Unknown Or Other (3), Electrical system (2), Suspension (2), Engine (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
01/24/2025 · Unknown Or Other
The seller tampered with the odometer, my mechanic found the codes stored in the car and printed the evidence out for me. I can provide it if need be and I have the sellers facebook account. Please let me know if there is anything else you need.
06/23/2017 · Fuel system
WHEN I DRIVE MY CAR IT STALLS OUT ON ME ALL THE TIME.. I AM AN 88 YEAR OLD WOMAN WHO HAS ONE CAR FOR MYSELF MY GREAT GRAND DAUGHTER WHO IS 15 AND MY SON WHO IS 50. THIS IS EXTREMELY SCARY BECAUSE I HAVE TO GET ON HIGHWAY 50 TO GET TO ANY STORES. IT HAS STALLED OUT ON ME 4 TIMES IN ONE TRIP BEFORE AND THERE ARE TIMES WHEN IT CAN TAKE OVER AN HOUR TO RESTART,…
06/14/2017 · Fuel system
I AM 88 YEARS OLD AND DEPEND ON THIS VEHICLE ( OUR ONLY VEHICLE) AS MY TRANSPORTATION FOR MYSELF MY SON AND MY 15 YEAR OLD GREAT GRAND DAUGHTER. MORE TIMES THAN I CARE TO REMEMBER THIS CAR HAS STALLED OUT ON ROUTE 50, WHERE I WAS TRAVELING 50 TO 55 MILES AN HOUR. I LIVE ABOUT 1 HOUR AWAY FROM OCEAN CITY, MARYLAND. EACH TIME IS TERRIFYING. SOMETIMES IT ONLY…
12/04/2016 · Electrical system
I DOVE MY CAR IN THE MORNING WHEN STOP IN THE MIDDLE OF STREET AND CALL TO AAA FOR TOWING TO FIX I BROUGHT THE ALTERNATOR I THINK THE WAS FIXED BUT I PUT THE NEW BATTERY DECEMBER 3 STILL MY CAR MAKE SOME NOISE I THINK IS ELECTRICAL PROBLEM BUT I DISCOVER HAS LEEK INSIDE THE PASSENGER SIDE BACK AND FRONT IS LIKE POOL I REALLY UPSET AND I DON'T KNOW HOW MUCH…
05/24/2016 · Unknown Or Other
FIRST THE RADIATOR OVER FLOW IS PLASTIC N CORRODED LEAKING RADIATOR FLUID SECOND THE CENTER COUNSEL GOES BAD WHERE YOU CAN NOT CONTROL THE AIR NOR HEAT ON THE DRIVERS SIDE IT GETS SO HOT IT BURNS YOUR FEET MAKING IT VERY UNBEARABLE, THE AIR STOPS WORKING ON DRIVERS SIDE
05/14/2014 · Airbags
2006 VOLVO V50. CONSUMER WRITES IN REGARDS TO VEHICLE AIRBAG SYSTEM. *SMD THE CONSUMER STATED THE AIR BAG LIGHT ILLUMINATED, AND IT READ "SRS AIRBAG SERVICE URGENT". THE CONSUMER STATED IT WAS THE SECOND TIME, THE LIGHT ILLUMINATED. THE FIRST TIME, THE LIGHT ILLUMINATED, HE TOOK THE VEHICLE TO THE DEALER TO HAVE IT FIXED, BUT THE REMEDY ONLY LASTED FOR…
05/01/2013 · Fuel system
MY VOLVO JUST SHUT OFF IN TRAFFIC ON RT 95 IN DC. THE CHECK ENGINE LIGHT CAME ON AND VEHICLE WOULD NOT START. I RESEARCHED THE RECALL FOR VOLVO FUEL SYSTEMS AND THE DEALER SAID I WAS NOT IN THE RECALL EVEN THOUGH MY YEAR, STATE AND I HAD THE EXACT PROBLEM. VERY FRUSTRATING. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),…
08/21/2012 · Suspension
3 SEPARATE ISSUES: 1. ELECTRICAL: POWER WINDOWS AND POWER LOCKS SPORADICALLY STOP WORKING. THIS STARTED HAPPENING AROUND MARCH OF 2011. THIS HAPPENS WITHOUT WARNING AND DOES NOT MATTER IF THE CAR IS IN MOTION OR NOT. 2. SUSPENSION: AFTER ONLY 33,000 MILES OF DRIVING IN SOUTHERN CALIFORNIA MILD WEATHER, SEVERAL PARTS OF THE SUSPENSION SYSTEM ARE BROKEN…