2005 Volvo S40 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
3 safety recalls, most serious first
1. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires.
What could happen: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
The fix: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2005 S40.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 10V566000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
Summary: VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Notes: VOLVO SAFETY RECALL NO. R231. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
2. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH T5 TURBO ENGINES, THE POLYAMIDE TUBE IN THE FUEL LINE IS SENSITIVE TO THE EXTREME TEMPERATURES THAT MAY OCCUR IN THE AREA WHERE THE TURBO/EXHAUST MANIFOLD IS LOCATED.
What could happen: THIS MAY POTENTIALLY RESULT IN FUEL LINE LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
The fix: DEALERS WILL CHANGE THE FUEL LINE MATERIAL TO TEFLON FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2005 S40.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 06V137000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE
Summary: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH T5 TURBO ENGINES, THE POLYAMIDE TUBE IN THE FUEL LINE IS SENSITIVE TO THE EXTREME TEMPERATURES THAT MAY OCCUR IN THE AREA WHERE THE TURBO/EXHAUST MANIFOLD IS LOCATED.
Consequence: THIS MAY POTENTIALLY RESULT IN FUEL LINE LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL CHANGE THE FUEL LINE MATERIAL TO TEFLON FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Notes: VOLVO RECALL NO. R158. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. ON CERTAIN VEHICLES SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, REOCCURRING, LONG-TERM EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS SUCH AS SALTY-WET CONDITIONS, IT IS…
What could happen: IF THIS OCCURS, THE CHECK ENGINE LIGHT MAY ILLUMINATE. IN SOME CASES, THE VEHICLE MAY FAIL TO START OR MAY STALL, INCREASING THE RISK OF A CRASH.
The fix: DEALERS WILL REPLACE THE PEM AND INSTALL IT IN A NEW LOCATION TO PREVENT CORROSION. THE RECALL BEGAN ON FEBRUARY 20, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2005 S40.
- Book a repair at any authorized Volvo dealer. Quote NHTSA campaign 08V033000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-458-1552.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: ON CERTAIN VEHICLES SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, REOCCURRING, LONG-TERM EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS SUCH AS SALTY-WET CONDITIONS, IT IS POSSIBLE FOR THE PUMP ELECTRONIC MODULE (PEM) TO BECOME CORRODED INTERNALLY. THIS CAN CAUSE A FAULTY SIGNAL TO THE FUEL PUMP, RESULTING IN LOW OR NO FUEL PRESSURE TO THE ENGINE.
Consequence: IF THIS OCCURS, THE CHECK ENGINE LIGHT MAY ILLUMINATE. IN SOME CASES, THE VEHICLE MAY FAIL TO START OR MAY STALL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PEM AND INSTALL IT IN A NEW LOCATION TO PREVENT CORROSION. THE RECALL BEGAN ON FEBRUARY 20, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Notes: VOLVO RECALL NO. 190. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2005 Volvo S40 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (21), Electrical system (20), Engine (17), Gasoline (12), Brakes (11).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
03/20/2024 · Transmission / drivetrain
The contact's wife owns a 2005 Volvo S40. The contact stated the vehicle was difficult to start for several days. Eventually, the failure progressed and the vehicle was not able to start. The check engine warning light was illuminated. The vehicle was repaired by the contact, a previous Volvo technician. The contact stated the failure was due to the pump…
09/24/2023 · Seat belts
The drivers seat belt does not lock/latch in properly. Everytime I enter the vehicle I reach for my seat belt and buckle myself, well so I thought I did. When I insert the belt it seems as though its buckles however once I start to drive the belt comes un done and it i always have to pull over to put it back on becsuse it locks the seat belt so I'm not able…
03/18/2021 · Fuel system
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP ELECTRONIC MODULE HAD FAILED DUE TO RUSTING AND CORROSION. THE FUEL PUMP ELECTRONIC MODULE WAS REPLACED AND THE FAILURE WAS REMEDIED. THE…
06/15/2020 · Fuel system
I WAS TOLD BY SHOP THAT WORK ON MY CAR THAT WERE A RECALL ON THE PVC VAUL ON THE 2005 VOLV S40 2.4. *TR
06/06/2020 · Fuel system
MY VEHICLE SHUTS OFF WHILE IM DRIVING IT. I TOOK IT TO A MECHANIC 3 TIMES AND WAS ADVISED ITS AN ISSUE WITH THE FUEL PUMP. I WAS ALSO ADVISED THIS IS AN KNOWN ISSUE WITH THIS PARTICULAR VEHICLE AND WAS PROVIDED A NHTSA CAMPAIGN ID # 08V033000. *TR
08/23/2019 · Engine
2005 VOLVO S40 ENGINE AIR CONDITIONING MALFUNCTIONED. WHEN THE PROBLEM FIRST BEGUN THE CAR WOULD BE COOL AT START THEN GET WARM UNTIL ONE DAY THE AIR CONDITIONING JUST QUIT WORKING. I READ ON THIS FORUM AUTHORIZED VOLVO DEALERSHIP ADMITS THIS IS A COMMON PROBLEM IN THIS YEAR/MAKE/MODEL. THE COMPRESSOR CLUTCH OR COMPRESSOR OR BOTH REQUIRED REPLACING. I…
04/08/2019 · Body / structure
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT THE REAR PASSENGER SIDE CARPET WAS SATURATED WITH WATER AFTER A RAIN STORM. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 45,506. *BF CONSUMER STATED THE FOAM IN ROOF OF CAR IS CRUMBLING A…
07/16/2018 · Fuel system
THE CAR STARTS MISSING THEN STALLS OUT AFTER ABOUT 30MILES OF DRIVING IT STALLED IN THE MIDDLE OF CROSSING A 4 LANE AND WAS ABOUT HIT.IT IS THE PEM THEY HAD RECALLS ON THEM BUT NOT MY CAR FOR SOME REASON