1993 Volvo 240dl recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-20. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Airbags (4), Wheels / tires (3), Vehicle Speed Control (2), Seat belts (2), Lights (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
06/13/2017 · Airbags
TL* THE CONTACT OWNS A 1993 VOLVO 240 STATION WAGON. WHILE WAITING FOR ONCOMING TRAFFIC TO PASS TO PULL INTO THE DRIVEWAY, THE DRIVER'S SIDE AIR BAG DEPLOYED WITHIN THE STEERING WHEEL. THE AIR BAG DEPLOYED WITH FORCE AND EMITTED A GRAY SUBSTANCE. THE VEHICLE WAS PULLED INTO THE CONTACT'S DRIVEWAY AND THE MANUFACTURER WAS NOTIFIED WEEKS LATER. THE DRIVER SUS…
07/28/2005 · Vehicle Speed Control
DT: CONSUMER STATED THAT A VEHICLE SHE WAS ABOUT TO PURCHASE HAD ODOMETER FRAUD INVOLVED. THE VEHICLE WAS 1993 VOLVO WAGON 240. THE CONSUMER WAS CONSIDERING PURCHASING THIS VEHICLE RAN A CAR FAX ON THE VOLVO. THE CAR FAX SHOWED THAT THE MILEAGE WAS INCREASING. THE ACTUAL MILEAGE WAS INCREASING AND CONSISTENT, COULD TELL THROUGH THE DMV RECORDS. THE LAST M…
07/04/2004 · Wheels / tires
I OWN A 1993 VOLVO 240 SEDAN. I AM SELLING IT AND UPON REMOVING THE "TEMPORARY USE SPARE" TO CLEAN OUT THE TRUNK, I SAW THAT THE TREAD HAS SEPARATED IN A SECTION ABOUT ONE FOOT OF THE CIRCUMPHRENCE. THIS TIRE HAS NEVER BEEN USED, IT HAS ALWAYS BEEN IN THE TRUNK. THE FOLLOWING INFORMATION IS PROVIDED FOR IDENTIFICATION PURPOSES: FIRESTONE TEMPORARY US…
03/01/2004 · Airbags · crash
WHILE VEHICLE WAS JUST PASSING THROUGH A TOLL BOOTH CONSUMER HEARD A POPPING NOISE. THEN, STEERING COLUMN BEGAN TO SHAKE, AND SUDDENLY AIR BAGS DEPLOYED. THIS CAUSED CONSUMER'S VEHICLE TO REAR END VEHICLE IN FRONT. BECAUSE OF AIR BAG DEPLOYMENT CONSUMER SUSTAINED FACE AND CHEST INJURIES, AND WAS HOSPITALIZED FOR ONE WEEK. *AK
01/10/2003 · Vehicle Speed Control
CONSUMER STATED THE ODOMETER STICKS INTERMITTENTLY. *TT *JB
06/17/2002 · Wheels / tires
THE METAL BELTS SEPARATED FROM TIRE, A SECOND TIRE EXPERIENCED TREAD SEPARATION, DUNLOP D65 A/S. *YH
05/21/2002 · Wheels / tires
LEFT FRONT WHEEL CAME OFF WHILE DRIVING DUE TO RUSTED LUGS: NUTS. NO INJURIES.*AK
01/19/2001 · Engine
THE ORIGINAL PART (VOLVO PART #3536202) HAS 3 HEAT SHIELDS MADE OF ALUMINUM WITH ASBESTOS INSIDE FOR INSULATION. THE HEAT SHIELDS ALLOW WATER TO REMAIN IN CONTACT WITH THE DOWNPIPE AND FACILITATE CORROSION. THIS CORROSION ALLOWS PREMATURE CRACKING OF THE WELDS. THE WELD FAILURES ALLOW EXHAUST TO LEAK OUT BEFORE IT LEAVES THE EXHAUST SYSTEM. I PURCHASED…