1992 Volvo 240dl recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Airbags (7), Wheels / tires (4), Transmission / drivetrain (4), Vehicle Speed Control (3), Brakes (3).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
02/29/2016 · Wheels / tires
TL* THE CONTACT OWNS A 1992 VOLVO 240 EQUIPPED WITH YOKOHAMA AVID TOURING S TIRES, SIZE: 185/70R14 (NA). WHILE DEPRESSING THE BRAKE PEDAL AT APPROXIMATELY 20 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE VEHICLE. THE CONTACT DISCOVERED THAT ALL FOUR TIRES WERE DEFLATED AND THE SIDEWALLS OF THE TIRES WERE FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHE…
12/06/2011 · Fuel system
TL* THE CONTACT OWNS A 1992 VOLVO 240. THE CONTACT STATED THAT HE PURCHASED A PLASTIC FUEL LINE (PART NUMBER: 3547865) BUT THE COMPONENT FAILED. THE DEALER WAS NOTIFIED OF THE FAILURE ADVISED THAT HE CONTACT THE MANUFACTURER. THE MANUFACTURER WAS CONTACTED WHO ADVISED THAT THEY WOULD RETURN HIS CALL WITHIN THE NEXT TWO DAYS AND OFFERED NO FURTHER ASSISTANCE…
09/23/2002 · Vehicle Speed Control
CONSUMER STATES WHILE SITTING THE CAR WILL ACCELERATE WITHOUT WARNING.*JB CONSUMER STATED THAT DURING THE FIRST INCIDENT, THE VEHICLE CLIMBED OVER THE PARKING LOT BUMPER RESULTING IN DAMAGE TO LEFT LOWER CONTROL ARM, LEFT LOWER BALL JOINT, STABILIZER BAR AND BOTH STABILIZER LINKS. IN THE LAST INCIDENT THE WINDSHIELD WIPER BROKE. THE DEALER COULD NOT FIND T…
09/10/2001 · Brakes
TRANSMISSION/PARKING BRAKE ARE DEFECTIVE. WHEN CONSUMER IS IN VEHICLE THERE IS A REMINDER OF VEHICLE'S SAFETY. DEALERSHIP IS AWARE OF PROBLEM.*AKCONSUMER STATES THAT THE GEAR SHIFT SAFETY INTERLOCK CABLE IS DEFECTIVE CAUSING THE KEY TO BE REMOVED FROM THE IGNITION SWITCH WITHOUT PUTTING THE TRANSMISSION GEAR LEVER IN PARK. CONSUMER STATED THAT THE SPARE…
08/29/2001 · Wheels / tires
WHILE DRIVING, RIGHT REAR TIRE EXPLODED. TWO HOLES WERE IN TIRE ALONG THE SEAM WHERE TREAD MEETS THE SIDEWALL. TIRE MELTED ON RIM AND A BLOW TORCH HAD TO BE USED TO REMOVE TIRE FROM RIM. SIZE P195/70R14/90SMTS. CONTACTED DEALER. *AK *YH
08/29/2001 · Wheels / tires
WHILE DRIVING, RIGHT REAR TIRE EXPLODED. TWO HOLES WERE IN TIRE ALONG THE SEAM WHERE TREAD MEETS THE SIDEWALL. TIRE MELTED ON RIM AND A BLOW TORCH HAD TO BE USED TO REMOVE TIRE FROM RIM. SIZE P195/70R14/90SMTS. CONTACTED DEALER. *AK *YH
10/23/2000 · Engine
THE VEHICLE CONTINUALLY SHUTS DOWN, SEVERAL REPAIR ATTEMPTS (IDLE SPEED MOTOR,VALVE AND THROTTLE BODY) WHICH HAVE TO NOT REMEDIED THE STALLING PROBLEMS. *MJS
10/23/2000 · Engine
THE VEHICLE CONTINUALLY SHUTS DOWN, SEVERAL REPAIR ATTEMPTS (IDLE SPEED MOTOR,VALVE AND THROTTLE BODY) WHICH HAVE TO NOT REMEDIED THE STALLING PROBLEMS. *MJS