1994 Toyota T100 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Steering
What's wrong, in plain English: If steering fails you can lose control of the car. ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE STEERING WHEEL IS REPEATEDLY TURNED UNDER CERTAIN CONDITIONS WHERE HIGH STEERING EFFORT AND POWER ASSIST ARE REQUIRED, FOR INSTANCE, WHEN FULLY TURNING THE WHEEL WHILE THE VEHICLE IS STOPPED, A FATIGUE CRACK MAY DEVELOP IN THE STEERING RELAY ROD.
What could happen: IF THE VEHICLE IS CONTINUED TO BE OPERATED IN THIS CONDITION, THE RELAY ROD MAY FRACTURE, INCREASING THE RISK OF A CRASH.
The fix: DEALERS WILL REPLACE THE STEERING RELAY ROD. THE RECALL BEGAN OCTOBER 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1994 T100.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 05V389000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-331-4331.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STEERING:LINKAGES:ROD:RELAY:CONNECTING
Summary: ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE STEERING WHEEL IS REPEATEDLY TURNED UNDER CERTAIN CONDITIONS WHERE HIGH STEERING EFFORT AND POWER ASSIST ARE REQUIRED, FOR INSTANCE, WHEN FULLY TURNING THE WHEEL WHILE THE VEHICLE IS STOPPED, A FATIGUE CRACK MAY DEVELOP IN THE STEERING RELAY ROD.
Consequence: IF THE VEHICLE IS CONTINUED TO BE OPERATED IN THIS CONDITION, THE RELAY ROD MAY FRACTURE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE STEERING RELAY ROD. THE RECALL BEGAN OCTOBER 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Notes: TOYOTA RECALL NO. SSC 50N. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Transmission / drivetrain (4), Engine (4), Airbags (4), Body / structure (2), Steering (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/06/2014 · Transmission / drivetrain
VEHICLE WOULD NOT START. SHIFT LEVER IN FIRST GEAR, CLUTCH PEDAL FULLY DEPRESSED AND CLUTCH BYPASS SWITCH ENGAGED. VEHICLE LURCHED FORWARD APPROXIMATELY ONE FOOT WHILE TURNING KEY NEARLY RAMMING INTO THE SIDE OF ANOTHER VEHICLE PARKED DIRECTLY IN FRONT OF DISABLED VEHICLE. VISUAL INSPECTION OF CLUTCH PEDAL SUPPORT ASSEMBLY, TOYOTA P/N 107-34010, REVEALED TW…
02/29/2012 · Body / structure
TL* THE CONTACT OWNS A 1994 TOYOTA T100. THE CONTACT STATED THAT WHILE IN REVERSE, THE FRONT DRIVER SIDE TIRE SUDDENLY DISCONNECTED FROM THE FRAME. THE CONTACT WAS UNABLE TO STEER THE VEHICLE. THE CONTACT HAD THE VEHICLE TOWED TO A LOCAL MECHANIC WHERE THE MECHANIC NOTICED EXTENSIVE RUST ON THE FRAME. THE MECHANIC ADVISED THE CONTACT THAT THE VEHICLE WAS…
03/30/2009 · Steering
TOYOTA REFUSES TO ACCEPT OUR COMPLAINT ABOUT OUR 1994 TOYOTA T-100. TOYOTA REFUSES TO ACKNOWLEDGE 05V389000 AS A VALID SOURCE FOR A COMPLAINT. TOYOTA STATES THAT THERE IS NO RECALL FOR OUR VEHICLE. WE NEVER RECEIVED ANY NOTICE FROM TOYOTA OF A RECALL. *TR
11/27/2006 · Engine
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE RODE ROUGH AND AT ONE POINT, OVERHEATED AND BLEW A HEAD GASKET. THE VEHICLE WAS TAKEN TO THE NEAREST INDEPENDENT MECHANIC SHOP, WHO DETERMINED THE HEAD GASKET WAS DEFECTIVE AND CAUSED SEVERE ENGINE DAMAGE. NO REPAIRS WERE MADE. THE MANUFACTURER WAS CONTACTED, AND DETERMI…
03/28/2006 · Steering
DT*: THE CONTACT STATED WHILE TURNING LEFT AT 5MPH THE VEHICLE IS DIFFICULT TO STEER. UPON INSPECTION THE CONTACT DETERMINED THERE IS A CRACK IN THE STEERING RELAY ROD. THERE IS A NHTSA RECALL, # 05V389000, REGARDING THE STEERING RELAY ROD. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE…
02/18/2003 · Transmission / drivetrain
I AM HAVING A PROBLEM WITH A DEFECT WITH THE CLUTCH AND ASSEMBLE NO LONGER BEING ATTACHED TO THE VEHICLE. I LOST USE WHEN I WAS DRIVING DUE TO THEM NO LONGER BEING ATTACHED AT THE WELDS AND WALLS! THIS WAS NOT FUNNY AND DANGEROUS. NOT BEING ABLE TO SHIFT AND NO LONGER ABLE TO START THE TRUCK. THE PEDAL WON'T EVEN TOUCH THE BUTTON TO ENGAGE THE TRUCK TO S…
11/05/2002 · Engine
CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE ANTIFREEZE IS LEAKING INTO THE ENGINE BLOCK AND THEN IS BEEN PASS INTO THE EXHAUST SYSTEM WHICH CONSUMER THINKS IS BURNING IT AND PASSING A WHITE SMOKE THAT GOES IN TO HIS HOUSE AND GIVING HIM SEVERE HEADACHES. DEALER WAS CONTACTED AND STATED THAT WILL ONLY GIVE HIM A CERTAIN AMOUNT OF MONEY AND NO…
09/30/2002 · Wheels / tires
THE TIRES I HAD REPLACED BECAUSE 3 OUT OF THE FOUR TIRES WERE DEFECTIVE. MR