2015 Toyota RAV4 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
What could happen: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
The fix: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2015 RAV4.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 14V828000 (manufacturer code SET-14B).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-866-405-4226.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT
Summary: Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
2. Trailer Hitches
What's wrong, in plain English: A vehicle part that may fail. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
What could happen: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
The fix: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2015 RAV4.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 15V011000 (manufacturer code SET-15A).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-866-405-4226.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: TRAILER HITCHES
Summary: Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
3. Steering
What's wrong, in plain English: If steering fails you can lose control of the car. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
What could happen: An unexpected loss of power steering increases the risk of a crash.
The fix: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2015 RAV4.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 15V144000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-331-4331.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: STEERING:ELECTRIC POWER ASSIST SYSTEM
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
4. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
What could happen: A battery short circuit increases the risk of a fire.
The fix: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Ow…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2015 RAV4.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 23V734000 (manufacturer code 23TB13 and 23TA13).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-331-4331.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2015 Toyota RAV4 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (85), Unknown Or Other (60), Steering (47), Engine (37), Body / structure (31).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
10/01/2026 · Steering
The steering "micro" sticking in steps for last 4 years. Talked to the Cedar Park Toyota dealership, they informed that there was no recall on the vehicle. But I found recall # 15V-144. I never received a recall notice. Always observes sticking a low speeds. Concerned about steering lock up. What should I do to fix it?
09/19/2026 · Steering
While driving my 2015 Toyota RAV4 XLE 2WD (2.5L, about 207,000 miles), the electric power steering assist failed instantly with no warning, making the steering wheel feel locked. At the same moment, the infotainment screen went black and rebooted. It has happened at freeway speeds and at low neighborhood speeds, including on 9/14 and 9/15/2026, and also mor…
08/19/2026 · Body / structure
In July 2026, the rear power liftgate on my Toyota RAV4 suddenly stopped operating properly and would not close. I was unable to push the hatch down normally and then noticed that one of the hinges appeared bent and the liftgate was misaligned. Because I needed to close the vehicle, I tried to lower the hatch very slowly, moving it down only a small amount…
06/25/2026 · Steering
The contact owns a 2015 Toyota Rav4. The contact stated that the radio was inoperable. The contact stated that the gauges failed to properly operate. While driving 65 MPH, the vehicle lost power steering functionality. Additionally, the rearview camera image was reversed before becoming inoperable. The ABS, AWD, and engine warning lights were illuminated. T…
05/26/2026 · Unknown Or Other
Car’s sunroof exploded while driving, was going about 55 on the highway and I heard a loud pop followed by the sound of breaking glass which I found to be my whole sunroof exploding from the inside out. This is dangerous because of the possibility of glass landing on people or in the car leading to potential injury. This issue is apparently one that happens…
05/19/2026 · Body / structure
Purchased less than 2 months ago from Performance Mitsubishi in Delray Beach FL. Lift gate was not opening and closing properly. Yesterday the hinges broke and lift gate won't shut. It appears there is a class action lawsuit for this issue. I am now responsible for fixing this because the dealership won't.
03/02/2026 · Electrical system · fire
On Friday February 27, 2026 as the vehicle was being driven it caught fire. Fire department and sheriffs office was called to the scene. Vehicle fire was put out but the whole front end burned.
01/12/2026 · Unknown Or Other
There were two recalls on paint chipping off the body of the car. The last one ended in Nov 2025 I think. BUT...there are many of us who had no idea there was a paint recall, me included. I brought my Rav (great car btw, no issues with how it runs at all) thru a car wash over Thanksgiving, and two softball size paint chips came off, probably due to high…