2018 Toyota RAV4 Hybrid recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
3 safety recalls, most serious first
1. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
What could happen: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
The fix: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2018 RAV4 HYBRID.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 19V503000 (manufacturer code SET19A).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-270-9371.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:OTHER:LABELS
Summary: Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
2. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
What could happen: An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
The fix: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2018 RAV4 HYBRID.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 17V831000 (manufacturer code H0Z for Toyota vehicles, and HLF for Lexus vehicles).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-331-4331.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:OTHER:LABELS
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
Remedy: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
3. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
What could happen: A battery short circuit increases the risk of a fire.
The fix: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Ow…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2018 RAV4 HYBRID.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 23V734000 (manufacturer code 23TB13 and 23TA13).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-331-4331.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Summary: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- Portable jump starter
- 2018 Toyota RAV4 Hybrid owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Unknown Or Other (5), Brakes (3), Transmission / drivetrain (2), Fuel system (2), Visibility (wipers / glass) (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/12/2025 · Brakes
The contact owns a 2018 Toyota Rav4 Hybrid. The contact stated that while operating the vehicle, the messages "Pre-Collision", "Braking Power Low", and "AWD System Malfunction" were displayed. The cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The contact stated that the failure had occurred…
06/18/2025 · Engine
The contact owns a 2018 Toyota Rav4 Hybrid. The contact stated that while receiving an oil change by a certified mechanic, the contact was informed that there was no coolant in the coolant reservoir. The mechanic confirmed that the radiator, hoses, and thermostat had failed and needed to be replaced. The vehicle was repaired; however, the failure persisted.…
02/14/2025 · Electrical system
The contact owns a 2018 Toyota Rav4 Hybrid. The contact stated that the vehicle was difficult to start. The contact recharged the vehicle and the vehicle restarted. The vehicle was taken to Toyo Cars, where it was diagnosed with an auxiliary battery failure. The dealer was contacted to order the part, but the part was not available. The vehicle was not repa…
05/27/2019 · Transmission / drivetrain
WHILE DRIVING ON LONG TRIP GOING SOUTH ON HWY 101, VEHICLE STARTED BUCKING AND JERKING GOING 70ISH MPH. EV LIGHT WOULD COME ON LIKE IT WANTED TO SWITCH TO EV MODE. IT HAPPENED GOING DOWN A STEEP GRADE NEAR SAN LUIS OBISPO. IT STOPPED WHEN WE GOT TO FLAT GROUND. ABOUT 25 MILES LATER IT DID IT AGAIN AND I WAS ABLE TO RECORD A QUICK VIDEO OF INSTRUMENT CLUSTER…
04/26/2019 · Transmission / drivetrain · crash
I PULLED INTO A PARKING SPOT. IT WAS SLOPED BACKWARD. THE CAR WAS STOPPED COMPLETELY, AND SILENT. I WAS DISTRACTED BY A MINOR TASK, AND THEN EXITED THE CAR, INADVERTENTLY WITH THE POWER ON AND THE TRANSMISSION IN DRIVE, NOT PARK. WHEN I NOTICED THAT I COULD NOT LOCK THE CAR, AND REALIZED THAT THE CAR WAS STILL ENERGIZED, I REACHED OVER AND PRESSED THE ON BU…
04/07/2019 · Unknown Or Other
WHILE ACTIVELY BRAKING AT LOW SPEED TO LINE UP TO A TICKET DISPENSER IN A PARKING GARAGE, THE CAR SUDDENLY ACCELERATED AS IF THE GAS PEDAL WAS FLOORED. I SLAMMED THE BRAKE AND THE CAR STOPPED AT ABOUT 10 FEET. THE PARKING ARM WENT OVER THE HOOD ABOUT HALFWAY. WHEN I TRIED TO REVERSE I SAW THE GEAR SHIFT HAD MOVED AND THE ENGINE WAS OFF.
03/16/2019 · Vehicle Speed Control
I WAS DRIVING ON THE FREEWAY WITH ADAPTIVE CRUISE CONTROL ON. OUT OF THE CORNER OF MY EYE, I SAW A VERTICAL RED LINE FLASH ONCE ON THE DASH DISPLAY. SUDDENLY THE CAR BRAKED AND CAME TO A COMPLETE STOP. THERE WAS ALSO A LOSS OF POWER AS I COULD NOT STEER THE CAR TO THE SHOULDER. THERE WAS NOTHING IN FRONT OF ME AT THE TIME. THANKFULLY THE TRUCK BEHI…
01/27/2019 · Body / structure
WE WERE DRIVING ON I 80 APPROXIMATELY 1 MILE WEST OF DIXON AT ABOUT 65MPH. THE DAY WAS SUNNY AND TEMPERATURE APPROXIMATELY 60F. THERE WAS NO OVERPASS NEARBY. WE THEN HEARD AN EXPLOSION LIKE A SHOTGUN BLAST AND GLASS CAME INTO THE PASSENGER COMPARTMENT THROUGH THE PARTIALLY OPEN SUNSHADE ON THE ROOF. NO ONE WAS INJURED. WE TOOK THE NEXT EXIT AND DISCOVERED T…