2001 Toyota Prerunner recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Body / structure (4), Suspension (3), Steering (1), Transmission / drivetrain (1), Unknown Or Other (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (7)
02/18/2016 · Steering
MY DAUGHTER WAS MAKING A RIGHT HAND TURN ON A CITY STREET WHEN THE BALL JOINT BROKE AWAY, THE LEFT SIDE TIRE SNAPPED OFF. IT WAS STILL STUCK TO THE BRAKE ROTOR AND SUSPENSION. IT RUINED THE BRAKE ALSO. THE TOW TRUCK EVEN HAD PROBLEMS PICKING IT UP.2ND THE REAR END SEAL HAS BROKE AWAY AND LEAKED ALL THE WAY OVER TO THE BRAKE. THE TIRES NOW LOCK UP WHEN TRYIN…
06/29/2015 · Suspension
TOOK MY TACOMA IN TODAY FOR SPARE TIRE RECALL. WORK WAS DENIED DUE TO FRAME RUST. I DID NOT RECEIVED ANY NOTICES BEFOREHAND UNTIL THIS ONE. I FEEL MY VEHICLE IS UNSAFE TO DRIVE. I HAVE OWNED MY TACOMA SINCE 2003.
08/21/2014 · Body / structure
FRAME IS RUSTED AND UNSAFE TO DRIVE. TOYOTA ISSUED A SPECIAL POLICY FOR 15 YEAR FRAME WARRANTY AND EVEN BOUGHT BACK TRUCKS FOR THIS ISSUE BUT THE WARRANTY DID NOT GET EXTENDED BECAUSE THE TRUCK WAS NOT UNDERCOATED IN 2011 TO EXTEND THIS 15 YEAR WARRANTY. TOYOTA OWNERS BEWARE CUSTOMER SERVICE IS HORRIBLE THEY WOULD NOT GIVE ME ANYTHING IN WRITING TO SUPPORT…
12/30/2013 · Body / structure
TL* THE CONTACT OWNS A 2001 TOYOTA PRERUNNER. THE CONTACT STATED THAT THE FRAME HAD DETERIORATED, MAKING THE VEHICLE UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
06/10/2009 · Airbags · crash
TL*THE CONTACT OWNS A 2001 TOYOTA PRERUNNER. WHILE MAKING A LEFT TURN AT 10 MPH, A VEHICLE TRAVELING 80 MPH CRASHED INTO THE FRONT DRIVER'S SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY AND THE CONTACT WAS INJURED. A POLICE REPORT WAS FILED. THE DEALER WAS NOTIFIED, BUT NOT THE MANUFACTURER. THE CURRENT MILEAGE WAS 92,000 AND FAILURE MIL…
08/24/2008 · Body / structure
FRAME IS HEAVILY CORRODED , SOME RUST PERFORATION EXISTS. TOYOTA HAS EXTENDED FRAME RUST COVERAGE FOR '95 TO '00. I DRIVE AN '01.*TR
06/21/2005 · Suspension
DRIVER'S SIDE BALL JOINT FELL OFF RESULTING IN THE ENTIRE WHEEL COMING OFF. THERE WAS NO FORWARNING OF THIS GOING TO OCCUR. TOOK IT TO THE LOCAL DEALER THEY REPLACED THE LOWER & UPPER BALLJOINTS AND THE LEFT LOWER BALL JOINT. ALSO, THEY REPLACED A TIRE AND REPLACED A BRAKE HOSE. THEY SAID TO BRING IT BACK IN JULY AND THEY WOULD REPLACE THE BALL JOINTS A…