2002 Toyota Highlander recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
2 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE…
What could happen: IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.
The fix: DEALERS WILL ROTATE THE SPECIFIED CLAMP. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2002 HIGHLANDER.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 02V208000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-331-4331.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
Summary: ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE UNDERSIDE OF THE BODY DUE TO MOVEMENT OF THE FUEL TANK, CAUSING THE NOZZLE TO BREAK.
Consequence: IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.
Remedy: DEALERS WILL ROTATE THE SPECIFIED CLAMP. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
2. Latches / locks
What's wrong, in plain English: Doors, hood or trunk may open unexpectedly. CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
What could happen: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
The fix: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2002 HIGHLANDER.
- Book a repair at any authorized Toyota dealer. Quote NHTSA campaign 04V181000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-331-4331.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Summary: CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Notes: TOYOTA RECALL NO. SSC 40B. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2002 Toyota Highlander owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Visibility (wipers / glass) (141), Vehicle Speed Control (31), Engine (31), Body / structure (25), Brakes (19).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
02/27/2020 · Airbags
MY AIR BAG LITE KEEPS POPING ON
05/29/2019 · Electrical system · fire
I SAW SOMEONE STEAL MY CAR AND TOLD THEM THEY HACKED. WINDSHIELD WIPERS WOULD SLOW UP AND DOWN. BURNING OF THE ELECTRICS WHEN TRY TO CHARGE. CAR STOPPING IN THE MIDDLE OF THE ROAD. CAR GOING ON AND OFF. THE MIDDLE OF THE ROAD, TURNING BACK ON. SPEED CONTROL MESSING UP. SECURITY WARNING GOING UP AND DOWN.. BATTERY WOULD SHUT ON AND OFF. CAR LOCKS GOING ON AN…
07/02/2018 · Vehicle Speed Control
ACCELERATOR STICIKING. VEHICLE ACCELERATES AT 4000 TO 5000 RPMS HAD VEHICE TOWED TO TOYOTA OF BEDFORD 440-809-8399
12/05/2017 · Vehicle Speed Control · crash
WHILE DRIVING HOME THE CAR ACCELERATED ON IT,S OWN AND WAS UNABLE TO STOP WITHOUT REARENDING ANOTHER CAR WITHALL THE DAMAGE TO MY CAR AS A MECHANIC I REPAIRED THE BODY ON MY OWN AFTER MAKING REPAIRS I WAS ABLE TO DRIVE THE CAR FROM THE SHOP I WORK AT TO MY HOUSE THE CAR WAS IDLING A LITTLE HIGH .I RETURNED TOWARD WORK THE NEXT MORNING TO SCAN THE CAR FOR H…
08/02/2017 · Visibility (wipers / glass)
DRIVER SIDE VISOR HAS 2 POSITIONS ONLY. DOWN OR UP. CANNOT ADJUST FOR TALLER DRIVERS.
04/14/2017 · Electrical system
THE AC LIKES TO BLOW HOT AIR WHEN IN THE MAX AC SETTING AND THE TEMP KNOB BEING IN THE COLDEST POSITION. NUT BEING THE TEMP SETTING GAUGE COMES LOOSE CAUSING THE AC TO BLOW HOT AIR. HAPPENS ANYTIME IF PARKED OR DRIVING.
04/01/2017 · Transmission / drivetrain
I HAVE HAD RECURRENT TRANSMISSION PROBLEMS THAT COST TH OUSANDS TO FIX BUT YET ARE NOT COMPLETELY RESOLVED.L JUST HAD MY TRANSMISSION COMPLETELY FAIL AFTER BEING SERVICED 17 MONTHS AGO. SINCE REPLACING IT, I STILL HAVE PROBLEMS WITH CLUNKING DIRT THING IN THE MORNING WHEN IT TRIES TO CHANGE GEARS. NOW THERE IS A VIBRATION AND I HAVE TO TAKE IT BACK TO THE S…
09/16/2016 · Vehicle Speed Control
VEHICLE WAS IN MOTION ON A CITY STREET GOING STRAIGHT SLIGHTLY DOWNHILL AND THEN UPHILL. THE WEATHER WAS CLEAR. SPEED WAS ABOUT 15-25 MPH. I WAS BRAKING TO SLOW THE CAR DOWN BUT THE CAR ACCELERATED ON ITS OWN ( TOYOTA CALLS IT "UNINTENDED ACCELERATION"). THE CAR CONTINUED ACCELERATING EVEN THOUGH I WAS PRESSING THE BRAKES AS HARD AS I COULD AND IT WAS NOW…