2025 Toyota Grand Highlander Later Release recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- 2025 Toyota Grand Highlander Later Release owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Unknown Or Other (9), Engine (8), Fuel system (4), Transmission / drivetrain (4), Body / structure (3).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
10/15/2026 · Fuel system
The vehicle exhibits abnormal fuel system behavior. When the vehicle reaches a low fuel condition (approximately 40–50 miles to empty), the fuel tank only accepts about 12 gallons, even though the listed tank capacity is 17.2 gallons. After refueling, the fuel gauge displays FULL and the “Distance to Empty” reading jumps to over 360 miles, which is inconsis…
10/13/2026 · Steering
I experienced a serious safety incident involving my 2025 Toyota Grand Highlander with approximately 14,000 miles. While driving on a straight interstate highway at approximately 70 mph, surrounded by other vehicles, the steering wheel suddenly made two to three sharp, forceful jerking movements to the left. Afterward, the steering wheel remained approximat…
10/09/2026 · Transmission / drivetrain
On 9/26 at about 10:15am, my husband and I were fully stopped at a red light with his foot on the brake. Without him touching the gas pedal, the car suddenly surged forward as if it had been accelerated. It stopped for a moment, then surged forward again. Because he was holding the brake, the car didn’t move much, but each surge caused a hard jolt that felt…
10/06/2026 · Transmission / drivetrain
While driving in neighborhood at around 25 mph car started to sputter and lose power. Started flashing on display regarding ADAS which all disengaged then hybrid system failure message displayed. Stopped car, called dealership and asked if safe to drive. They said it was ok and set appointment for next morning, they contacted Toyota and confirmed it nee…
09/30/2026 · Body / structure
Driving in city traffic during morning rush hour, sitting at traffic light, when display lights up indicating “Hybrid Malfunction” and “take vehicle to dealer”. Leaving traffic light, the vehicle at first does not move after pressing accelerator, then slowly engages and thugs along. Pull over on closest side street and turn off vehicle, hoping just a fluk…
09/28/2026 · Engine
Engine temperature overheated during long idle on an out of town event. The vehicle put in park and engine running in idle with AC running. Vehicle coolant temp reach high mark in the red area. Vehicle temp alarm gave a warning to shutdown. I estimated the car idle time 40 min due to traffic accident ahead. The incident occurred on 9/11/26. The car was…
09/21/2026 · Engine
The contact owned a 2025 Toyota Grand Highlander. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with radiator failure. The contact was informed that there was a hole in the radiator. The contact was informed that the radiator needed to be…
09/18/2026 · Engine
A piece of road debris/rock struck the radiator/heat exchangers in my 2025 Toyota Grand Highlander Hybrid that immediately damaged the radiator/heat exchangers to result in coolant leakage and sudden loss of propulsion and terminated the engine from moving and required a tow to a Toyota dealer and thus a replacement of the heat exchanger/radiator. It cam…