1998 Toyota Avalon recalls & complaints

Component: ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
Summary: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES, MINI VANS AND PASSENGER VEHICLES EQUIPPED WITH A THEFT DETERRENT SYSTEMS (TDS) SUPPLIED BY AUDIOVOX CORPORATION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN 'OPEN CIRCUIT' CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.
Consequence: THIS CONDITION CAN CAUSE INTERMITTENT PERFORMANCE OF THE VEHICLE'S ELECTRICAL COMPONENTS SUCH AS THE DASH WARNING LIGHTS AND/OR HVAC FAN SPEED CONTROLS. ALSO, THE VEHICLE MAY NOT RUN SMOOTHLY AND COULD STALL.
Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING OCTOBER/NOVEMBER 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA DISTRIBUTOR AT 1-800-301-6859. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
Summary: EQUIPMENT DESCRIPTION: AFTERMARKET THEFT DETERRENT SYSTEMS USED ON 1998-1998 TOYOTA RAV4, AVALON, AND SIENNA MODEL VEHICLES DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN "OPEN CIRCUIT" CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.
Consequence: THIS CONDITION CAN CAUSE INTERMITTENT PERFORMANCE OF THE VEHICLE'S ELECTRICAL COMPONENTS SUCH AS THE DASH WARNING LIGHTS AND/OR HVAC FAN SPEED CONTROLS. ALSO, THE VEHICLE MAY NOT RUN SMOOTHLY AND COULD STALL.
Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.
Notes: OWNER NOTIFICATION IS BEING HANDLED BY SOUTHEAST TOYOTA DISTRIBUTORS. OWNER NOTIFICATION BEGAN NOVEMBER 3, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA DISTRIBUTOR AT 1-800-301-6859. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

06/26/2023 · Steering · crash
Tie rods detached from frame, along with steering parts became unsafe on minor highway speed turnes

06/26/2023 · Seat belts
All plastic parts are disintegrating, seer belts, door locks, door handles, AC vents , body trim, steering wheel, lights, & anything made of plastic

12/03/2018 · Suspension
ELECTRICAL SYSTEM SHUT DOWN IN TRAFFIC AT THE LIGHT, ALTERNATOR WAS TESTED. BATTERY LIGHT STAY ON, LIGHTS DIMMED OUT, LOST SPEED. HAD TO GET PUSHED OUT THE ROAD AT A BUSY INTERSECTION IN ATLANTA GEORGIA ON CLEVELAND AVENUE.. BOUGHT A SECOND ALTERNATOR, SAME EXACT INCIDENT . ONCE HEADLIGHTS ARE TURNED ON AT NIGHT, CAR LOOSES TOTAL POWER. I HAD TO DRIVE FIVE…

04/25/2018 · Vehicle Speed Control
TL* THE CONTACT OWNS A 1998 TOYOTA AVALON. THE CONTACT STATED THAT THE THROTTLE BECAME STUCK WITHOUT WARNING. AS A RESULT, THE CONTACT DROVE THROUGH TWO RED LIGHTS. THE CONTACT HAD TO MANEUVER BETWEEN THE ACCELERATOR PEDAL AND THE BRAKE PEDAL TO STOP THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, ESTABLISHED A CASE NUMBER, AND REFERRED THE CONTA…

02/11/2017 · Airbags
ONE DAY WHEN MY CAR WAS STATIONARY AND AFTER IT HAD SET FOR A FEW DAYS I STARTED IT NORMALLY AND NOTICED THE SRS AIRBAG WARNING LIGHT ON MY DASH CAME ON. THIS IS BEEN ABOUT A MONTH NOW AND A LOCAL MECHANIC SAID THE CODE READING INDICATES THERE IS AN ISSUE WITH THE PASSENGER SIDE AIRBAG. THE MECHANIC SAID IT IS A DEFECTIVE AIRBAG. THEY SAID IT MIGHT NOT DEPL…

11/01/2016 · Electrical system
TL* THE CONTACT OWNS A 1998 TOYOTA AVALON. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED INTERMITTENT PERFORMANCE OF VARIOUS ELECTRICAL SYSTEMS. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOTIFIED. THE CONTACT REFERENCED NHTSA CAMPAIGN N…

08/10/2016 · Electrical system
WHEEL LOCKED THEN THE CAR WILL NOT START, ALARM SYSTEM LIGHT WON'T BLINK AND I'M HEARING A WINEING NOISE UNDER THE HOOD.

05/09/2014 · Electrical system
TL* THE CONTACT OWNS A 1998 TOYOTA AVALON. THE CONTACT STATED THAT UPON START UP, THE KEY WOULD NOT TURN IN THE IGNITION NOR WOULD THE VEHICLE START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE IGNITION SWITCH. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO ANOTHER MECHANIC WHO ALSO REPLACED THE IGN…