2004 Mitsubishi Outlander recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Visibility (wipers / glass)
What's wrong, in plain English: You may not be able to see the road clearly. ON CERTAIN SPORT UTILITY VEHICLES LOCATED IN THE CARIBBEAN, DUE TO A SOFTWARE PROGRAMMING ERROR IN THE ELECTRONIC TIMING AND CONTROL SYSTEM (ETACS), WHILE USING THE INTERMITTENT WIPER MODE, THE INTERMITTENT WIPER SWEEP TIME INTERVAL MAY INCREASE AS MUCH AS 6.8 SECOND BETWEEN WIPER SWEEPS.
What could happen: IF THIS OCCURS DURING SEVERE WEATHER AND DURING VEHICLE'S HIGH-SPEED OPERATION, THE DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD LEAD TO A CRASH.
The fix: DEALERS WILL REPLACE THE ETACS MODULE. OWNER NOTIFICATION BEGAN NOVEMBER 14, 2003. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-800-981-0452.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2004 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 03V429000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-981-0452.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VISIBILITY:WINDSHIELD WIPER/WASHER
Summary: ON CERTAIN SPORT UTILITY VEHICLES LOCATED IN THE CARIBBEAN, DUE TO A SOFTWARE PROGRAMMING ERROR IN THE ELECTRONIC TIMING AND CONTROL SYSTEM (ETACS), WHILE USING THE INTERMITTENT WIPER MODE, THE INTERMITTENT WIPER SWEEP TIME INTERVAL MAY INCREASE AS MUCH AS 6.8 SECOND BETWEEN WIPER SWEEPS.
Consequence: IF THIS OCCURS DURING SEVERE WEATHER AND DURING VEHICLE'S HIGH-SPEED OPERATION, THE DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE ETACS MODULE. OWNER NOTIFICATION BEGAN NOVEMBER 14, 2003. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-800-981-0452.
Notes: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
2. Trailer Hitches
What's wrong, in plain English: A vehicle part that may fail. CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN EQUIPPED WITH DEALER-INSTALLED TRAILER HITCH WIRING HARNESS AND CONTROL MODULE. THE ELECTRONIC CONTROL MODULE CAN OVERHEAT.
What could happen: OVERHEATING OF THE TRAILER HITCH WIRING HARNESS MODULE COULD RESULT IN A FIRE.
The fix: OWNERS ARE BEING REQUESTED TO STOP USING THE HARNESS UNTIL A NEWLY DESIGNED REPLACEMENT IS PROVIDED AND CAN BE INSTALLED BY THE DEALER. THE RECALL BEGAN ON MAY 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-888-648-7820.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2004 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 04V197000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-648-7820.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: TRAILER HITCHES
Summary: CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN EQUIPPED WITH DEALER-INSTALLED TRAILER HITCH WIRING HARNESS AND CONTROL MODULE. THE ELECTRONIC CONTROL MODULE CAN OVERHEAT.
Consequence: OVERHEATING OF THE TRAILER HITCH WIRING HARNESS MODULE COULD RESULT IN A FIRE.
Remedy: OWNERS ARE BEING REQUESTED TO STOP USING THE HARNESS UNTIL A NEWLY DESIGNED REPLACEMENT IS PROVIDED AND CAN BE INSTALLED BY THE DEALER. THE RECALL BEGAN ON MAY 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-888-648-7820.
Notes: MITSUBISHI RECALL NO. SR-04-004. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
3. Suspension
What's wrong, in plain English: Parts can break and cause loss of control. Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania,…
What could happen: A detached front control arm can result in the loss of control of the vehicle, increasing the risk of a crash.
The fix: MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one that has a sealing/anti-corrosion agent applied to it. These repairs will be perform…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2004 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 16V458000 (manufacturer code SR-16-003).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-888-648-7820.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
Summary: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.
Consequence: A detached front control arm can result in the loss of control of the vehicle, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one that has a sealing/anti-corrosion agent applied to it. These repairs will be performed free of charge. The recall began January 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-003.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
4. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
What could happen: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
The fix: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURI…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2004 OUTLANDER.
- Book a repair at any authorized Mitsubishi dealer. Quote NHTSA campaign 04V428000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-787-251-8715.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:OTHER:LABELS
Summary: CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
Notes: THE MANUFACTURER'S PETITION WHICH REQUESTED THAT NHTSA DETERMINE THIS FMVSS NONCOMPLIANCE DOES NOT CREATE AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY WAS PARTIALLY DENIED ON JANUARY 26, 2005. THEREFORE, THIS MANUFACTURER IS OBLIGATED TO CONDUCT AN OWNER NOTIFICATION AND REMEDY CAMPAIGN.
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2004 Mitsubishi Outlander owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Suspension (20), Body / structure (8), Engine (8), Airbags (7), Lights (6).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/25/2022 · Suspension
The contact owns a 2004 Mitsubishi Outlander. The contact stated that while driving at a slow speed, the front subframe detached. The contact stated that the driver’s side front wheel was pointing outwards. The contact received notification of NHTSA Campaign Number: 16V458000 (Suspension) however, the part to do the recall repair was not yet available. The…
10/05/2021 · Suspension
The entire undercarriage is rusted out, it was taken to Ricart near columbus ohio where they simply sprayed an anti rust coating over the existing rust. There is now rusted holes and the vehicle has spun out driving in straight due to control arm issues and whatever else. The vehicle is not believed to be road safe and needs to be addressed.
10/29/2020 · Steering
THE FRONT CONTROL ARM WHERE IT BOLTS TO THE K FRAME RUSTED AWAY COMPLETLY RESULTING IN THE FRONT DRIVERS TIRE TO COME OFF. WAS IN A GET IN GO PARKING LOT TURNING WHEN THIS HAPPENED LUCKLY NO ONE WAS HURT.
02/24/2020 · Suspension
REAR SUBFRAME RUSTED THROUGH WHILE MOVING SLOWLY IN DRIVEWAY CAUSING THE DRIVER'S SIDE REAR WHEEL TO MISALIGN, MAKING THE CAR UNABLE TO MOVE. CAR WAS TOWED TO REPAIR SHOP WHERE REAR SUBFRAME WAS REPLACED.
11/23/2018 · Body / structure
TL* THE CONTACT OWNS A 2004 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT THE VEHICLE'S SUBFRAME FRACTURED DUE TO RUST. THE VEHICLE WAS TAKEN TO DES MOINES MITSUBISHI (4475 MERLE HAY RD, DES MOINES, IA 50310, (515) 270-8100) FOR AN UNKNOWN RECALL REPAIR THAT INVOLVED EITHER REPLACING THE SUBFRAME OR APPLYING AN ANTI-CORROSION FLUID. THE CONTACT STATED THAT…
04/03/2018 · Suspension
2004 MITSUBISHI OUTLANDER. CONSUMER WRITES IN REGARDS TO CORROSION RECALL NOTICE INSTRUCTION ISSUES - DEALERSHIP APPLIED CORROSION SPRAY TO FRONT CROSS MEMBER AND LOWER CONTROL ARM BEFORE CONSULTING CONSUMER. *SMD *TR
11/09/2017 · Suspension
TL* THE CONTACT OWNS A 2004 MITSUBISHI OUTLANDER. WHILE DRIVING 25-30 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE REAR SUSPENSION WAS FRACTURED AND THAT THE DRIVER'S SIDE REAR WHEEL SEPARATED FROM THE VEHICLE. THE CONTA…
10/20/2017 · Body / structure
I RECEIVED A SAFETY RECALL REGARDING THE FRONT CROSS BODY REGARDING RUST AND CORROSION. MY FRONT CROSS BODY FAILED WITH TOTAL RUST THROUGH. MECHANIC SHOWED ME THAT THE REAR CROSS BODY IS ALSO AFFECTED AND HAS A RUST THROUGH HOLE THE SIZE OF MY FIST. MITSUBISHI HAS REFUSED TO COVER THE REAR. THIS IS A TRUE SAFETY HAZARD AND NEEDS TO BE COVERED BY MITSUBI…