2020 Mercedes-Benz Sprinter 2500 Cargo recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2020 Mercedes-Benz Sprinter 2500 Cargo owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (20), Transmission / drivetrain (18), Engine (15), Forward Collision Avoidance (14), Brakes (13).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
08/12/2026 · Forward Collision Avoidance
What component or system failed or malfunctioned, and is it available for inspection upon request? The Adaptive Cruise Control turns off and then won't reset while driving. When the Adaptive Cruise Control turns off and then won't reset while driving. How was your safety or the safety of others put at risk? This causes the vehicle to immediately loose pow…
05/14/2026 · Engine
Sudden complete engine failures occurred in my Mercedes-Benz Sprinter van during highway operation while transporting freight, creating a serious safety hazard due to immediate and total loss of engine power in active traffic conditions. The first engine failure occurred at approximately 303,000 miles. The second failure occurred at approximately 140,000 m…
12/09/2025 · Electrical system · fire
On November 28, 2025, I experienced a vehicle fire in my Mercedes 2020 Sprinter 2500 4WD van. The van engine was on and idling while heating up with the van heater blower on level 6 (out of 7). After about 45 minutes, I saw a haze first and then smelled smoke. Unsure of the source, I turned the vehicle off and exited with my dog. I opened the hood to look f…
12/07/2025 · Brakes
I had 5 recalls completed at the MB Sprinter dealership in Pleasanton CA on 11/06/2025. Had hardly driven it 100 miles or 5 times since then when I noticed it was not always going into park. One recall had to do with not going in park when you push park button while foot on brake. I was not having that problem until the MB Sprinter dealership did the recall…
09/11/2025 · Transmission / drivetrain
I’ve had two issues with my sprinter van that were transmission shift module that left me stranded with no way to shift the car into neutral. I was blocking a fuel pump and couldn’t get the car into gear. The first time I was stuck in a parking lot with the same issue. I can’t believe no one else had this issue. The screen message said “Service required do…
08/25/2025 · Electrical system
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that while in reverse, the rearview camera failed to display a rearview image. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to provide a cause for the failure. The vehicle was not repaired. After investigating the failure, the contact related t…
07/17/2025 · Transmission / drivetrain
repeated EGR clogging and malfunction: bucking or stumbling behavior, inability to accelerate properly, disabled shifting affecting ability to slow or stop without excessive use of brakes, Limp Home Mode suddenly without warning including inability to maintain a safe speed on highway and speed minimums that the vehicle cannot keep up (20 mph max while climb…
04/16/2025 · Transmission / drivetrain
While driving the vehicle, 4x4 and low range would engage on its own. It would cause the transfer case to grind, clunk, and lock up. This happened while the vehicle was in motion and could have easily sent the vehicle out of control. Some warning lights appeared on the dash. I took it into the dealership, they diagnosed it as a glitch in the transfer case…