1998 Lincoln Navigator recalls & complaints

Component: EXTERIOR LIGHTING
Summary: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: VEHICLE SPEED CONTROL
Summary: ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Consequence: A FIRE AT THE SWITCH COULD OCCUR.
Remedy: BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Notes: FORD RECALL NO. 05S28. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: WHEELS:LUGS/NUTS/BOLTS/STUDS
Summary: VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES AND LIGHT DUTY PICKUP TRUCKS. THE LUG NUTS ON THESE VEHICLES MAY NOT CREATE SUFFICIENT CLAMP LOAD ALLOWING WHEEL MOVEMENT IN RELATION TO THE HUB/ROTOR MOUNTING SURFACE.
Consequence: THIS CAN RESULT IN THE LOOSENING OF LUG NUTS, STUD FATIGUE FAILURE, AND THE POTENTIAL FOR A WHEEL SEPARATION FROM THE VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: OWNERS OF THESE VEHICLES WILL BE RECEIVING TWO NOTIFICATIONS. THE FIRST NOTIFICATION, WHICH BEGAN IN MAY 1998, WILL PROVIDE AN INTERIM REPAIR PROCEDURE UNTIL PARTS BECOME AVAILABLE. THIS INTERIM PROCEDURE CAN BE COMPLETED BY OWNERS OR THEIR DEALERS. IT SPECIFIES THAT THE LUG NUT TORQUE MUST BE VERIFIED TO BE 100 LBS. THEN THE LUG NUTS NEED TO BE TIGHTENED AN ADDITIONAL 1/8 TO 1/4 TURN MORE. THERE WILL BE A SECOND OWNER NOTIFICATION, WHICH IS EXPECTED TO BEGIN JULY 20, 1998, UNDER WHICH DEALERS WILL INSPECT THE WHEEL STUDS AND REPLACE THE WHEEL LUG NUTS.
Notes: OWNERS WILL BE RECEIVING TWO NOTIFICATIONS. THE FIRST NOTIFICATION, WHICH BEGAN IN MAY 1998, WILL PROVIDE AN INTERIM REPAIR PROCEDURE. THERE WILL BE A SECOND OWNER NOTIFICATION, WHICH IS EXPECTED TO BEGIN JULY 20, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: TRAILER HITCHES
Summary: VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES. THE TRAILER HITCH ASSEMBLY TO THE FRAME ATTACHING BOLTS COULD LOSE THE CLAMP LOAD.
Consequence: THE TRAILER HITCH COULD THEN SEPARATE FROM THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TRAILER HITCH MOUNTING BOLTS AND NUT PLATES.
Notes: OWNER NOTIFICATION BEGAN MAY 15, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Summary: VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. IF THE AUTOMATIC TRANSMISSION SHIFT CABLE ASSEMBLY WAS NOT FULLY ATTACHED TO THE STEERING COLUMN BRACKET, THE SHIFT CABLE ASSEMBLY CAN COME OUT OF THE BRACKET. THE VEHICLE OPERATOR WOULD THEN NOT BE ABLE TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION EVEN THOUGH THE GEAR SHIFT SELECTOR WOULD INDICATE "PARK."
Consequence: THE CONDITION WOULD NOT ALLOW A DISENGAGEMENT OF THE TRANSMISSION FROM THE PARK POSITION OR AFFECT PROPER NEUTRAL START SWITCH OPERATION. UNINTENDED VEHICLE MOVEMENT COULD OCCUR IF THE PARKING BRAKE WAS NOT SET.
Remedy: DEALERS WILL MAKE THE PROPER ATTACHMENT OF THE TRANSMISSION SHIFT CONTROL CABLE TO THE STEERING COLUMN BRACKET AND ADD A TIE STRAP TO THAT CONNECTION.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 20, 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: EXTERIOR LIGHTING:HEADLIGHTS
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.
Remedy: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN MARCH 23, 1998. OWNERS WHO DO NOT RECEIVE THE FREE OWNER GUIDE WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

04/12/2018 · Transmission / drivetrain
TL* THE CONTACT OWNS A 1998 LINCOLN NAVIGATOR. WHILE ATTEMPTING TO PLACE THE VEHICLE IN PARK, THE GEAR SHIFTER FAILED TO ENGAGE. THE CONTACT STATED THAT THE VEHICLE WOULD ROLL FORWARD OR BACKWARDS, DEPENDING ON IF THE VEHICLE WAS ON AN INCLINE OR A DECLINE. THE CONTACT WAS CONCERNED ABOUT THE ROLLAWAY POSSIBILITIES WITH THE VEHICLE. THE VEHICLE WAS NOT TAKE…

07/18/2016 · Suspension
TL* THE CONTACT OWNS A 1998 LINCOLN NAVIGATOR. WHILE DRIVING APPROXIMATELY 65 MPH, THE REAR OF THE VEHICLE INDEPENDENTLY SWAYED FROM SIDE TO SIDE WITHOUT WARNING. IN ADDITION, THE CONTACT MENTIONED THAT THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO RESPOND AND THE REAR OF THE VEHICLE BEGAN TO SCRAPE ACROSS THE GROUND. THE CONTACT MENTIONED THAT THE VEHICLE S…

06/22/2016 · Airbags · crash
TL* THE CONTACT OWNED A 1998 LINCOLN NAVIGATOR. WHILE DRIVING 40 MPH, THE CONTACT CRASHED INTO THE FRONT OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT FAILED TO RESTRAIN THE CONTACT IN PLACE. A POLICE REPORT WAS FILED. THE CONTACT SUFFERED A MILD CONCUSSION AND A WHIPLASH, BUT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS DESTROYE…

04/20/2016 · Suspension · crash
I WAS DRIVING ABOUT 40 MPH ON A RODE A DROVE EVERYDAY SOMETHING BROKE ON MY 98 LINCOLN NAVIGATOR . THE GUYS WHO FLIPPED IT BACK OVER SAID THE SUSPENSION BROKE I SCRAPED A GUARDRAIL THEN STRAIGHT ACROSS THE ROAD HEAD ON WITH A TREE I FLIPPED UP ON MY HEADLIGHTS SPUN LIKE THAT THEN ROLLED 50 MORE FEET DOWN THE ROAD IT KNOCKED ME OUT ON IMPACT BUT A FRIEND WAS…

04/08/2016 · Suspension · crash
WHEELS ARE NOT SAFE AND VERY DANGEROUS AND RANDOMLY BREAKING OFF ALL SCREWS WHILE DRIVING AND RUINED THE FRAME AND DRIVE SHAFT TRANSMISSION SUSPENSION ETC... HIGHWAY 10 WEST AND VEHICLE BECAME UNSTOPPABLE AS BRAKES ALSO NEW BUT FAILED WITHOUT 4TH WHEEL THIS OCCURRED 1ST ON MORNING AFTER ST PATRICKS DAY 2016 AND THE TIRES WERE GOOD AND WHEELS WERE BOLTED WIT…

03/04/2016 · Transmission / drivetrain
TL* THE CONTACT OWNS A 1998 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THE GEAR INDICATOR ON THE INSTRUMENT CLUSTER FAILED TO DISPLAY THE DESIRED GEAR SELECTION. IN ADDITION, THE GEAR LEVER WOULD NOT SHIFT INTO THE PARK POSITION PROPERLY. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 97V171000 (POWER TRAIN). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTUR…

03/12/2015 · Transmission / drivetrain
TL* THE CONTACT OWNS A 1998 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THE GEAR SHIFT FAILED TO GO INTO THE PARK POSITION. IN ADDITION, THE CONTACT STATED THAT THE IGNITION KEY FAILED TO DISENGAGE FROM THE IGNITION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 187,000.

03/05/2015 · Lights · crash
STARTED WITH THE LIGHT IN VEHICLE STAYING ON FOR HOURS AT A TIME CAUSING A LOUD NOISE UNDER HOOD. WHILE DRIVING AND PICKING UP MY GIRLFRIEND, WE WERE SCARED BY THE SUDDEN ACCELERATION OF MY VEHICLE. WE HIT ANOTHER CAR CAUSING OUR HEADS TO HIT THE DASH BOARD. THE CAR WOULDN'T STOP SO AFTER WE HIT A CAR WHILE ON BREAKS, I THROUGH CAR IN PARK AND THAT JUST MA…