2005 Lincoln Aviator recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Body / structure (28), Transmission / drivetrain (12), Airbags (3), Steering (3), Suspension (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
11/05/2020 · Suspension
I WAS DRIVING ON A HIGHWAY 55 MPH WHEN PASSENGER REAR TOE LINK FAILED AND I LOST CONTROL OF VEHICLE. I WAS ABLE TO PULL OVER WITHOUT CRASHING. VEHICLE WAS REPAIRED AT GARAGE NEARBY.
07/10/2020 · Body / structure
A 6 INCH CRACK DEVELOPED AT REAR CENTER TAILGATE BODY PANEL MADE OUT OF PLASTIC BELOW THE REAR WINDOW. THERE HAD BEEN REPORTS THAT THE REAR WINDOW COULD FALL OUT AND INTERNAL TAILGATE COMPONENTS COULD BE DAMAGED DUE TO WATER ENTRY FROM THE CRACK. THIS APPEARS TO BE A COMMON PROBLEM FROM MY RESEARCH.
02/25/2020 · Airbags
DRIVER SIDE AIR BAG DEPLOYED WITH NO IMPACT OF ANY KIND. CAR WAS STARTED AND AIR BAG DEPLOYED.
12/27/2019 · Body / structure
REAR PLASTIC LITIGATE APPLIQUE BROKE OFF HITTING A PASSENGER CAR'S WINDSHIELD. THE WINDSHIELD CRACKED. THIS THE THIRD PIECE FAILURE. THE LINCOLN WAS TRAVELING WEST ON THE DULLES GREENWAY.
10/17/2016 · Body / structure
WHILE PARKED AT THE GAS STATION GETTING READY TO PUMP GAS THE REAR WINDOW EXPLODED, GLASS SHATTERED EVERYWHERE, LEFT HINGE CRACKED AND FRAME AROUND LIFTGATE BEND AND CURLED UP. MY REAR LIFTGATE HAS THE SAME CRACKED AS PREVIOUSLY REPORTED. I REPLACED THE ENTIRE LIFTGATE IN 2011 & ON THE NEW LIFTGATE THE SAME CRACK CAME BACK
09/14/2016 · Body / structure
I HAVE THE SAME CRACKING PROBLEM WITH THE BACK GATE WHICH RESULTED IN THE BREAKING OF HINGES. ALSO A KNOWN DEFECT IN USING DEFECTIVE PARTS IN THE ENGINE SUCH AS TIMING CHAIN CASSETTES AND TENSIONER. FORD KNEW ABOUT THE PROBLEM AND ISSUED AN TECHNICAL BULLETIN ON IT BUT NEVER FIXED THE PROBLEM. THE MECHANIC TOLD ME HE REPAIRED THIS VERY FREQUENTLY FOR THIS E…
07/21/2015 · Transmission / drivetrain
OWNER OF 2005 LINCOLN AVIATOR. I WAS NOT ABLE TO GET THE GEAR SHIFT OUT OF PARK. I HAD THE AVIATOR TOWED TO A FAMILY MEMBER'S AUTOMOTIVE GARAGE AND WAS TOLD THAT I WILL NEED TO HAVE THE ENTIRE GEAR SHIFT REPLACED. UPON DOING SOME RESEARCH, IT SEEMS THAT THIS IS A VERY COMMON PROBLEM IN THIS YEAR, MAKE, AND MODEL. I HAVE READ ENDLESS TESTIMONIES FROM OTH…
02/24/2015 · Body / structure
WHEN PURCHASED USED 2 YRS OLD [XXX], I NOTICED A CRACK IN THE MIDDLE OF THE LIFTGATE. I HAVE OWNED THIS VEHICLE FOR ALMOST 7YRS AND HAVE TAKEN VERY GOOD CARE OF IT, BUT I NOW HAVE 3 CRACKS IN THE LIFTGATE. IT SEEMS TO BE VERY THIN ACROSS THE BOTTOM OF THE BACK WINDOW AND EVERY TIME YOU OPEN AND CLOSE THE WINDOW, IT PUTS STRESS ACROSS THE BOTTOM OF IT. TH…