2005 Kia Rio recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Child seat
What's wrong, in plain English: A child restraint may not protect the child properly. CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECA…
What could happen: IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR.
The fix: DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2005 RIO.
- Book a repair at any authorized Kia dealer. Quote NHTSA campaign 05V557000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-333-4542.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: CHILD SEAT
Summary: CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.
Consequence: IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Notes: KIA RECALL NO. SC057. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2005 Kia Rio owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (17), Airbags (4), Seat belts (4), Electrical system (4), Steering (3).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
10/05/2026 · Unknown Or Other
On [XXX], while driving my 2005 Kia Rio northbound on [XXX] across the [XXX], I was coming from a meeting in Louisville, Kentucky, and heading toward Jeffersonville, Indiana. While I was driving, the hood (bonnet) of my vehicle suddenly and unexpectedly flipped up and slammed into the windshield. The hood struck the windshield with such force that it compl…
11/13/2020 · Steering · crash
I WAS DRIVING ON PUBLIC STREET LOSS CONTROL DUE TO A POT HOLE IN THE STREET THE CAR LOST CONTROL FLIPPING SLIDING THEN FLIP UP RIGHT TILL IT CAME TO A STOP ON APT WALL THEN WHEN IT WAS ALL OVER AND DONE THE AIRBAG DEPLOYED GO OFF ON MY ARM RIGHT ARM GIVING ME SECOND TO THIRD DEGREE BURNS THE PURPOSE OF THE AIR BAG ? I HAVE BROKEN BACK CAR WAS TOTALED NOW I…
01/19/2016 · Airbags
TL* THE CONTACT OWNS A 2005 KIA RIO. THE CONTACT STATED THAT THE AIR BAG AND SEAT BELT WARNING LIGHTS RANDOMLY FLASHED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V244000 (AIR BAGS); HOWEVER, THE CONTACT DID NOT RECEIVE A RECALL NOTIFICATION. THE VEHICLE WAS TO BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING AND REPAIR. THE MANUFACTURER WAS NOTIFIED…
01/08/2016 · Steering
WHEN THE CAR IS EXPOSED TO MOISTURE, EITHER FROM UNDERNEATH BY DRIVING THROUGH A SMALL PUDDLE OR FROM ABOVE IN A RAINSTORM, THE ENGINE COMPARTMENT GETS WET AND CAUSES THE SERPENTINE BELT TO SLIP. THIS RESULTS IN SUDDEN LOSS OF POWER STEERING AND ALTERNATOR FAILURE, WHICH CAN LEAD TO THE CAR'S POWER CUTTING OUT IN THE MIDDLE OF THE ROAD. THIS IS AN OBVIOUS…
09/24/2015 · Engine
TL* THE CONTACT OWNS A 2005 KIA RIO. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT HAD TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD TO A COMPLETE STOP. THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING BELT FRACTURED AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT RE…
11/23/2014 · Visibility (wipers / glass)
THE BLOWER STOPPED BLOWING AIR. FOR A SHORT WHILE IT WOULD COME ON, RARE OCCASIONS AND EVENTUALLY STOPPED WORKING. CHANGED THE BLOWER MOTOR AND RESISTOR, STILL DIDN'T WORK. PULLED THE DASH APART TO CHANGE THE BLOWER SWITCH AND FOUND THAT IT HAD MELTED THE PLASTIC CONNECTOR. NOT SURE WHAT CAUSED THE MALFUNCTION, HOWEVER ONCE THE NEW SWITCH WAS PUT IT THE BL…
08/29/2014 · Engine
NOT REALLY A SAFETY ISSUE BUT MAYBE YOU CAN HELP, PLEASE. I CHECK ENGINE LIGHT CAME ON TELLING ME I'M AT LESS THAN 90% EFFICIENCY RELATIVE TO POLLUTION. WHEN THE MECHANIC CHECKS THE CO2 AND OTHER POLLUTION REQUIREMENTS I'M OK. I STILL GET GREAT MILEAGE AND GOOD POWER. THE PROBLEM IS THE COMPUTER SAYS THE CONVERTER IS OFF AND HENCE CAN'T GET A STICKER BUT…
05/16/2014 · Body / structure
KIA RIO 2005 IS A VERY POORLY BUILT CAR. THE PASSENGERS DOOR WILL NOT OPEN, A MECHANISM IN THE DOOR IS BROKEN. SINCE THE DOOR WON'T OPEN NO ONE SEEMS TO KNOW HOW TO REPAIR THIS PROBLEM. THE DOOR PANEL CAN NOT BE REMOVED FROM THE DOOR WITHOUT THE DOOR BEING OPEN. NEVER AGAIN WILL I BUY A KIA OF ANY KIND. *TR