1998 Honda Passport recalls & complaints

Component: SUSPENSION:REAR
Summary: ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
Notes: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
Summary: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES THAT ARE EQUIPPED WITH AN ANTI-LOCK BRAKING SYSTEM (ABS). THE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES IN CERTAIN TYPES OF BRAKING EVENTS.
Consequence: EXTENDED STOPPING DISTANCE COULD RESULT, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL PROVIDE A REPLACEMENT COMPUTER ALGORITHM FOR THE ABS THAT IS BASED ON THE ALGORITHM USED IN HONDA'S MY 2000 AND 2001 VEHICLES, WHICH HAVE NOT HAD THE PROBLEM. THIS CAMPAIGN WILL BE CONDUCTED IN PHASES, WITH THE MY 1998 2WD VEHICLES COVERED FIRST, SINCE THEY HAVE EXPERIENCED THE MOST PROBLEMS. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009.
Notes: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SUSPENSION:REAR
Summary: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070, EXT. 343. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: UNKNOWN OR OTHER
Summary: VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH A DRIVER'S SIDE OPTIONAL EQUIPMENT RUBBER FLOOR MAT. REPEATED MOVEMENT OF THE DRIVER'S FEET AND ACTUATION OF THE ACCELERATOR PEDAL CAN RESULT IN A SHIFTING OF THE MAT'S POSITION. THIS SHIFTING CAN CAUSE AN INTERFERENCE WITH THE ACCELERATOR PEDAL.
Consequence: THIS COULD CAUSE A RESTRICTION OF THE PEDAL'S RETURN TO THE IDLE POSITION, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: HONDA IS ASKING FOR THE RETURN OF THE FLOOR MAT SET AND WILL REIMBURSE OWNERS FOR THE COST OF THE RUBBER FLOOR MAT SET ALONG WITH ANY RETURN SHIPPING COSTS.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING DECEMBER 1997. OWNERS WHO SEND THEIR FLOOR MAT SET TO HONDA AND DO NOT RECEIVE THE REIMBURSEMENT WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
Summary: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN AUGUST 20, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
Summary: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. A GROUND CONNECTION TERMINAL WAS NOT PROPERLY CRIMPED IN THE SUPPLIER'S ENGINE WIRING HARNESS MANUFACTURING LINE. THIS IMPROPER CRIMPING PROCESS CAN LEAVE AN IMPRESSION ON THE TERMINAL THAT WILL EVENTUALLY CAUSE A STRESS FRACTURE. S
Consequence: IF A TERMINAL IS FRACTURED, THE POWERTRAIN CONTROL MODULE (PCM) CAN RECEIVE AN ERRONEOUS SIGNAL INDICATING A HIGH VEHICLE SPEED, THEREBY CAUSING THE PCM TO CUT THE FUEL, CAUSING A 'NO-START' CONDITION, OR A POSSIBLE ENGINE STALL.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE VEHICLES.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN AUGUST 24, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-255-6727 OR HONDA AT 1-800-999-1009. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

12/13/2018 · Transmission / drivetrain
TL* THE CONTACT OWNS A 1998 HONDA PASSPORT. WHILE DRIVING 55 MPH, THE ENGINE AND TRANSMISSION WARNING INDICATORS ILLUMINATED. IN ADDITION, WHILE ACCELERATING FROM A STOP, THE VEHICLE JERKED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE GENERAL MOTOR CODE 1870 (TRANSMISSION) NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN…

07/11/2017 · Body / structure
TL* THE CONTACT OWNS A 1998 HONDA PASSPORT. THE CONTACT STATED THAT THE VEHICLE EXHIBITED SEVERE RUST ON THE REAR PASSENGER SIDE FRAME. THE CONTACT RECEIVED A RECALL NOTICE IN NHTSA CAMPAIGN NUMBER: 10V436000 (SUSPENSION) WAS RECEIVED BACK IN 2011 AND THE VEHICLE WAS REPAIRED AT WILLIAMS HONDA IN TRAVERSE CITY, MICHIGAN. THE VEHICLE WAS TREATED WITH AN ANTI…

12/29/2014 · Body / structure
I BOUGHT A 1998 HONDA PASSPORT AT THE AUCTION IN SALEM NEWHAMPSHIRE ON DECEMBER 20, 2014, THE VEHICLE HAS AN ESTIMATE OF 87;000 MILES ON IT, WHICH IS WHY I BOUGHT THE CAR IN THE FIRST PLACE ON TOP OF THE FACT THAT THE VEHICLE APPEARED TO BE IN GOOD CONDITION, HOWEVER TO MY SURPRISE AFTER TAKING MY CAR TO THE MECHANIC, I WAS TOLD THAT THE FRAME TO THE VEHICL…

08/29/2014 · Suspension
DRIVING STARTED TO SWAY SLIGHTLY FOR NO APPARENT REASON, ON THE WAY HOME THERE WAS A SUDDEN GRINDING AND LOSS OF CONTROL OVER THE VEHICLE STAYING IN ONE LANE, I PULLED IT OVER TO THE SIDE OF THE ROAD AND LOOKED AT IT. THE REAR TRAILING ARM RUSTED AND SEPARATED FROM THE FRAME. HUNDREDS OF COMPLAINTS OVER THIS ISSUE AS WELL AS COMPLAINTS THAT CANADA IS REIMBU…

02/24/2014 · Suspension
TL* THE CONTACT OWNS A 1998 HONDA PASSPORT. THE CONTACT WAS DRIVING 55 MPH WHEN THE VEHICLE BEGAN TO BOUNCE AND VEER WITHOUT THE CONTACT TURNING THE STEERING WHEEL. THE CONTACT IMMEDIATELY TOOK THE VEHICLE FOR INSPECTION. THE CONTACT WAS AWAITING THE DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE…

08/21/2013 · Suspension
I TOOK MY HONDA PASSPORT TO FOX HONDA, TO GET THE RECALLS LOOKED AT AND THEY SAID THAT THE FRAME WAS RUSTED OUT AND THAT IT WAS UNSAFE TO DRIVE, SO THEY SAID THE RECALL FOR THE FRAME HAD ENDED ALREADY SO THEY COULDN'T DO ANYTHING ABOUT IT. THEY LET ME DRIVE THE HONDA OFF THERE LOT KNOWING THAT I COULD GET IN A WRECK. THERE'S GOT TO BE A MANDATORY RECALL ON…

11/20/2012 · Suspension
TL* THE CONTACT OWNS A 1998 HONDA PASSPORT. THE CONTACT STATED WHILE DRIVING 20 MPH AND MAKING A RIGHT TURN THE VEHICLE BECAME UNCONTROLLABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INSPECTED THE FRAME AND NOTICED THAT THERE WAS RUST AND CORROSION ALL OVER THE FRAME. THE VEHICLE WAS THEN TAKEN TO THE DEALER WHO NOTIFIED HIM OF RECALL NHTSA CAM…

10/31/2012 · Suspension
TL* THE CONTACT OWNS A 1998 HONDA PASSPORT. THE CONTACT STATED THAT WHILE TRAVELING 30 MPH, THE VEHICLE VEERED INTO ANOTHER LANE ABNORMALLY. THE CONTACT WAS ABLE TO MERGE TO THE SIDE OF THE ROAD WHERE THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC. AFTER INSPECTION, THE CONTACT WAS ADVISED THAT THE REAR SUSPENSION HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE…