2005 Harley-Davidson Flhtcui recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- 2005 Harley-Davidson Flhtcui owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Brakes (2), Hydraulic (2), Electrical system (2), Engine (1), Vehicle Speed Control (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (5)
09/18/2013 · Engine
HARLEY DEALERSHIP TOLD ME TO UPGRADE THE CAM TENSIONER ON THE TWIN CAM 88 MOTOR FROM 1991-1996. THEY HAVE A TENDENCEY TO "EXPLODE" AFTER 20-25K MILES. $500 FOR THE PART #25284-11, $500-$1000 FOR LABOR. THERE IS NOTHING IN THE SERVICE MANUALS FOR CHECKING THIS PART. TO REPLACE IT REQUIRES A COMPLETE MOTOR TEAR DOWN. THIS SHOULD BE RECALLED FOR A MOTOR PART…
10/17/2006 · Brakes
2005 HARLEY ULTRA REAR BRAKES FAILED. *TS THE FRICTION MATERIAL HAD FALLEN OFF THE BACKING PLATE. THE CONSUMER REPLACED THE PADS HIMSELF. ALMOST TWO MONTHS LATER THE REAR WHEEL DEVELOPED A 10 INCH SPLIT WHICH CAUSED THE BIKE TO OPERATE ERRATICALLY. THE BIKE WAS TOWED TO THE DEALER WHERE THEY REPLACED THE WHEEL UNDER WARRANTY. AFTER THE TECH PUT THE NE…
09/06/2006 · Brakes
DT*: THE CONTACT STATED WHILE TRAVELING 50 MPH, THE HYDRAULIC REAR BRAKE DID NOT WORK AT ALL. THE FRONT BRAKE HAD TO BE APPLIED TO STOP THE VEHICLE. THERE WAS NO WARNING PRIOR TO THE BRAKING. THE ROAD CONDITION WAS HARD SURFACED. ALSO, THE SECOND TIME THE FRONT BRAKE LINING PAD HAD FRACTURED. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER BUT WAS UNABLE…
05/09/2006 · Electrical system
NO EVENTS OTHER THAN POOR WORKMANSHIP. HORN DOESN'T WORK. SAFETY IS MY CONCERN. HARLEY-DAVIDSON SAYS THERE IS NOTHING WRONG WITH MY HORN. THEY SAY THAT AT 2000 RPM WHEN YOU PRESS THE HORN BUTTON IT WORKS. SITTING STILL OR IDLING THE HORN WILL NOT WORK. THEY SAY NO ONE USES THE HORN AT IDLE OR SITTING STILL. IF I AM SITTING AT A LIGHT AND SOMEONE TURNS…
05/09/2006 · Electrical system
HARLEY DAVIDSON HORN DOESN'T WORK. THE HORN WAS REPLACED AT 1000 MILES. STILL DOESN'T WORK. IT SOUNDS LIKE A WOUNDED DUCK. HARLEY DEALER SAYS THE HORN IS FINE AND THAT YOU MUST BE RUNNING THE ENGINE AT 2000 RPM FOR THE HORN TO WORK. IT WORKED FINE WHEN PURCHASED. I SAY ITS A DEFECT IN MANUFACTURING. IF YOU NEED THE HORN YOU MUST BE DRIVING AT 2000 RPM…