2007 Harley-Davidson Flhtc recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- 2007 Harley-Davidson Flhtc owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (6), Transmission / drivetrain (5), Lights (2), Brakes (1), Wheels / tires (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
12/29/2016 · Transmission / drivetrain
TL* THE CONTACT OWNS A 2007 HARLEY-DAVIDSON FLHTC. WHILE RIDING 75-80 MPH, AN ABNORMAL NOISE EMITTED FROM THE TRANSMISSION. THE DEALER DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MOTORCYCLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. UPDATED 04/06/17 LJ *TR
09/28/2014 · Brakes
THE REAR BRAKE LINE (PN 40971-00A) RUBBED THE FRAME AND CLUTCH CABLE, CAUSING A HOLE TO BE CREATED. THIS IS IN THE AREA BELOW THE CAM CHEST, BEHIND THE MASTER CYLINDER, INSIDE THE FRAME ON THE RIGHT SIDE. THE BRAKE LINE BLEW OUT WHEN THE REAR BRAKE WAS APPLIED. THERE WAS NO WARNING. AFTER DOING RESEARCH, I FOUND THIS TO BE A COMMON PROBLEM. *TR
09/05/2014 · Lights
TL* THE CONTACT OWNS A 2007 HARLEY DAVIDSON FLHTC. THE CONTACT STATED THAT WHILE DRIVING AT 9 MPH, THE BRAKE LAMP FAILED TO ACTIVATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT MENTIONED THAT THE BRAKE LAMP SWITCH WAS MELTED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LIGHT SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT R…
07/24/2014 · Transmission / drivetrain
AS I WAS SLOWING DOWN IN MY DRIVEWAY THE ENGINE, WITH OUT WARNING, MADE A LOUD METALLIC NOISE FROM THE LEFT SIDE AND LOCKED UP ALONG WITH THE REAR WHEEL. IF THIS WOULD HAVE HAPPENED AT A GREATER SPEED, OR IN TRAFFIC, THE CONSEQUENCES COULD HAVE BEEN DIRE. I REMOVED THE PRIMARY COVER AND IMMEDIATELY NOTICE A LARGE PIECE OF STEEL HAD GOTTEN JAMMED BETWEEN T…
03/19/2013 · Wheels / tires · crash
WHILE RIDING THE MOTORCYCLE (2007 HARLEY DAVIDSON HERITAGE SOFTAIL CLASSIC) AT 57 MPH ON DRY PAVEMENT WITH NO ADVERSE ROAD CONDITIONS, THE REAR TIRE BLEW, THE RIDER FOUGHT TO KEEP THE BIKE UPRIGHT TO SLOW DOWN FOR 3-5 SECONDS, THEN LOST CONTROL AND CRASHED ON THE HIGHWAY. THE TIRE PRESSURE WAS CHECKED TO PROPER INFLATION 30 MINUTES BEFORE THE BLOWOUT AND AC…
09/08/2009 · Electrical system
WHEN SWITCH TO HIGH BEAM ALL LIGHTS GO OUT BECAUSE THE 15 AMP FUSE WILL BLOW. *TR
04/27/2009 · Engine
TL*THE CONTACT OWNS A 2007 HARLEY DAVIDSON FLHTC MOTORCYCLE. THE CONTACT STATED HIS EXHAUST PIPE TURNED RED AFTER OVERHEATING. THE OVER HEATING IS CAUSED BY THE EXHAUST PIPE AND CYLINDER HEAD. THE DEALER IS WAITING FOR APPROVAL FROM THE REGIONAL MANAGER TO MAKE THE REPAIRS. THE FAILURE MILEAGE WAS 2,800.
06/05/2008 · Engine
MY 2007 FLHTC HARLEY DAVIDSON HAS BEEN A LEMON SINCE I BOUGHT IT IN 2007. THE BIKE ALWAYS RUNS HOT DUE TO THE FACT THERE IS NO OIL PRESSURE AT TIMES. THE CPK UNIT WENT OUT AND LEAKED OIL EVERYWHERE AFTER ONE MONTH. THE FRONT PART OF THIS UNIT, WHICH WAS INSIDE THE MOTOR, WAS DAMAGED. THE DEALERSHIP SAID SOMETHING HAD TO HAVE HIT IT. INSTEAD OF TEARING DOWN…