1996 Harley-Davidson Flht recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Electrical system
What's wrong, in plain English: Wiring, modules, batteries. Short circuits can cause stalls or fires. VEHICLE DESCRIPTION: FL TOURING MOTORCYCLES. A LOSS OF ELECTRICAL POWER THROUGH THE IGNITION SWITCH CAN OCCUR DUE TO EXCESSIVE CURRENT AND OTHER FACTORS.
What could happen: THIS CONDITION CAN CAUSE THE ENGINE TO FAIL TO START, OPERATE ERRATICALLY, OR STALL.
The fix: DEALERS WILL REPLACE THE IGNITION SWITCH/CIRCUIT BREAKER AND INSTALL A RELAY KIT.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1996 FLHT.
- Book a repair at any authorized Harley-Davidson dealer. Quote NHTSA campaign 98V158000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ELECTRICAL SYSTEM:IGNITION:SWITCH
Summary: VEHICLE DESCRIPTION: FL TOURING MOTORCYCLES. A LOSS OF ELECTRICAL POWER THROUGH THE IGNITION SWITCH CAN OCCUR DUE TO EXCESSIVE CURRENT AND OTHER FACTORS.
Consequence: THIS CONDITION CAN CAUSE THE ENGINE TO FAIL TO START, OPERATE ERRATICALLY, OR STALL.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH/CIRCUIT BREAKER AND INSTALL A RELAY KIT.
Notes: OWNER NOTIFICATION BEGAN JULY 20, 1998. OWNERS WHO TAKE THEIR MOTORCYCLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4680. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Portable jump starter
- 1996 Harley-Davidson Flht owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (6), Engine (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (7)
05/07/1999 · Electrical system
CONSUMER RECEIVED NHTSA RECALL 98V158000 CONCERNING IGNITION SWITCH FAILURE. ON 28 JUL 98. ON ABOVE DATE CONTACTED DEALER TO HONOR RECALL. DEALER INFORMED CONSUMER THAT PARTS WOULD BE AVAILABLE IN AUGUST OR OCTOBER 30 1998. HOWEVER, RECALL HAS STILL NOT HONORED AT THIS TIME. *AK
02/08/1999 · Engine
H-D REDESIGNED THE TAPPETS IN THE EVO BIG TWIN MOTOR. MY MOTOR HAD 3 OF THE NEW STYLE TAPPETS AND ONE OF THE OLD TAPPETS INSTALLED IN IT. THE ROLLERS IN THE OLD STYLE TAPPET DISINTEGRATED, CAUSING METAL SHAVINGS PUMPED THROUGHOUT THE ENGINE. A PIECE OF METAL GOT INTO THE OIL PUMP ,AND CAUSED A LOSS OF OIL PRESSURE, WHICH THEN CAUSED THE ENGINE TO GET NOISY.…
12/09/1998 · Electrical system
OWNER HAS RECEIVED A RECALL NOTICE JULY 22 1998. CONSUMER HAS CONTACTED DEALER SEVERAL TIMES AND THE PROBLEM HAS NOT BEEN TAKEN CARE OFF.
10/15/1998 · Electrical system
THE AMOUNT OF REPAIR KITS FOR IGNITION SWITCH THAT ARE BEING SHIPPED FROM THE MANUFACTURER TO THE DEALERS ARE GREATLY INSUFFICIENT. THE DEALER HAS BEEN CONTACTED SEVEN TIMES, AND CANNOT OBTAIN THE KITS AND CANNOT DETERMINE WHEN THEY WILL BE IN. *AK
09/23/1998 · Electrical system
IGNITION SWITCH EXPERIENCES INTERMITTENT FAILURE, RECALL NOTICE SENT HOWEVER UNABLE TO BE REPAIRED DUE TO LACK OF PARTS.
09/09/1998 · Electrical system
IGNITION SWITCH HAS FAILED SEVERAL TIMES.
06/15/1998 · Electrical system
IGNITION SWITCH FAILURE, WHILE OPERATING THE MOTORCYCLE, CAUSING THE MOTORCYCLE TO COME TO A SCHREECHING HALT WHILE DRIVING. THE DEALER WAS CONTACTED AND WOULD REPLACE THE SWITCH , STATED THAT THEY WERE AWARE OF THE PROBLEM AND MANY HAD BEEN REPLACED FOR A FEE. *AK