2002 GMC Safari recalls & complaints

Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Summary: ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE ENTIRE MULTIFUNCTION SWITCH WILL BE REPLACED. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes: GM RECALL NO. 05013. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: FUEL SYSTEM, GASOLINE
Summary: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: EXTERIOR LIGHTING
Summary: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes: THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

05/08/2018 · Wheels / tires
ON MAY 5, 2018 TRAVELING ON I-40, MILE 398 WHILE TRAVELING IN THE MIDDLE LANE I HEARD A LOUD NOISE AND MY VAN STARTED SHAKING. I KNEW/FELT THAT A TIRE HAD BLOWN. I GOT TO THE SIDE OF THE ROAD AND GOT HELP. THE TIRES WERE PURCHASED AND PUT ON NOVEMBER OF 2016. THE TIRES ARE GOODYEAR WRANGLERS WITH 8,789 MILES ON THESE TIRES..

11/15/2017 · Airbags · crash
TL* THE CONTACT OWNS A 2002 GMC SAFARI. WHILE DRIVING 45 MPH, THE CONTACT'S VEHICLE WAS STRUCK ON THE DRIVER'S SIDE BY A 2006 DODGE CARAVAN. THE CONTACT'S VEHICLE THEN CRASHED INTO A POLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED LOWER BACK PAIN, A BRUISED TOE, A FOREHEAD GASH, AND DAMAGE TO THE RIBS. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPOR…

10/04/2013 · Brakes
FRONT BRAKE LINE RUSTED OUT AND FAILED, NECESSITATING EXPENSIVE REPAIR AND REPLACEMENT. *TR

05/18/2010 · Transmission / drivetrain
THE REAR AXLE BROKE AND THE LEFT WHEEL & AXLE CAME COMPLETELY OUT OF THE HOUSING. *TR

06/08/2009 · Brakes
MY 2002 GMC SAFARI WOULD NOT START. I WENT AND REPLACED THE 2.5 YEAR OLD BATTERY (IT WAS LEAKING AT THE TERMINALS) IT STARTED ONE TIME AND THEN ABOUT 45 MINUTES LATER IT WAS DEAD AGAIN. IT WAS TOWED TO THE DEALER. I WAS FIRST INFORMED THAT THE CHARGING SYSTEM WAS O.K. AND THAT THE PROBABLE CAUSE WAS THE BATTERY WAS NOT FULLY CHARGED. I WAS THEN INFORMED THA…

04/17/2008 · Steering
TL*THE CONTACT OWNS A 2002 GMC SAFARI. WHILE DRIVING 5 OR 6 MPH, IT TOOK 40-50 FEET BEFORE THE CONTACT COULD STOP THE VEHICLE. A MECHANIC STATED THAT BOTH THE PASSENGER AND DRIVER SIDE WHEEL BEARINGS AND IDLER ARMS NEEDED TO BE REPLACED. THE LOCAL MECHANIC PERFORMED THE REPAIRS. GMC DENIED HIM REIMBURSEMENT BECAUSE THEY DID NOT MAKE THE REPAIR. THE CONS…

03/19/2008 · Electrical system
THE GRAND AM SEEMS TO HAVE A PROBLEM WITH ITS ANTI THEFT DEVISE IF YOU GO TO EDMANS.COM YOU WILL SEE MANY COMPLAINTS TO THIS PROBLEM AS WELL AS MANY MORE. WE ARE ALL GETTING STRANDED AND SPENDING THOUSANDS OF DOLLARS TRYING TO FIX THIS PROBLEM. G.M. NEEDS TO LOOK INTO THIS AND DO A RECALL FOR THIS PROBLEM. *TR

02/25/2008 · Lights
TL*THE CONTACT OWNS A 2002 GMC SAFARI. THE CONTACT STATED THAT THE BRAKE LIGHTS WORKED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THEY STATED THAT THE REPAIR REQUIRED THEM TO DISMANTLE SOME OF THE MAJOR COMPONENTS TO BETTER ACCESS THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED REQUESTING INFORMATION ON…