2002 Freightliner Sprinter recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- 2002 Freightliner Sprinter owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (2), Transmission / drivetrain (2), Suspension (1), Electrical system (1), Wheels / tires (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
01/12/2007 · Engine
WE PURCHASED SEVERAL 2002 FREIGHTLINER SPRINTERS AND HAVE HAD MANY PROBLEMS INCLUDING 2 ENGINE REPLACEMENTS. THESE VEHICLES ARE JUST OUT OF THE 6,00 MILE WARRANTY. THE CHRYSLER CORP ASSISTED ON THE REPAIRS 2 HOWEVER WE NOW HAVE A 3RD VEHICLE THAT HAS 71543 MILES ON IT AND THE CHRYSLER CORP IS REFUSING TO OFFER ANY ASSISTANCE IN THE REPAIR. IF THIS WAS…
09/29/2006 · Suspension
DT*: THE CONTACT STATED WHILE ACCELERATING UPHILL AT VARIOUS SPEEDS IN VARIOUS ROAD CONDITIONS, THERE WAS A VIBRATION PHYSICALLY FELT THROUGH THE FLOORBOARD. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED THE TORQUE ARM CONVERTER AND PLATE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED.
04/19/2006 · Engine
I HAVE HAD FOUR SEPARATE OCCASIONS WHEN THE EGR VALVE ON MY SPRINTER HAS LEAKED OIL ALL OVER THE MOTOR AND HAD TO BE REPLACED. THE COST FOR THIS REPAIR IS NOW OVER $500.00 EACH OCCURRENCE. THE AVERAGE MILEAGE FOR THIS FAILURE IS 25,000 MILES. NOT RIGHT FOR A MERCEDES BENZ PRODUCT THAT DOESN'T HAVE THIS PROBLEM IN EUROPE. *JB
08/24/2005 · Transmission / drivetrain
DT: THE CONSUMER HAS 2002 FREIGHTLINER SPRINTER VAN HAD A CARRIER BEARING ON THE DRIVESHAFT WHICH SEIZED AND SPINNED OUT. THE CONSUMER TOOK THE DRIVESHAFT TO A REPAIR SHOP TO HAVE IT CHECKED. THE MECHANIC SUGGESTED THAT THE CONSUMER REPLACE THE DRIVESHAFT. THE CONSUMER MADE SEVERAL CALLS TO THE DEALERSHIP, AND THEY TOLD HIM THAT IT IS WAS ONLY WARRANTED…
05/17/2005 · Transmission / drivetrain
TRANSMISSION PROBLEM. I HAVE EXPERIENCED THE FOLLOWING PROBLEM ON DIFFERENT TYPES OF TERRAIN, BUT IT HAS BEEN MOST COMMON IN AREAS WITH STEEP HILLS. AFTER ACCELLERATING TO MAINTAIN SPEED WHILE CLIMBING A STEEP INCLINE AND FEATHERING THE THROTLE AS THE HILL IS TOPPED, THE (AUTOMATIC) TRANSMISSION KICKS COMPLETELY OUT OF GEAR ON THE DESCENT AND WILL NOT RE-…
01/25/2005 · Electrical system
WHILE DRIVING 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONSUMER TRIED TO RESTART THE VEHICLE AND WAS ABLE TO DO SO. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC COULD NOT DUPLICATE THE PROBLEM AT THIS TIME. PLEASE PROVIDE FURTHER DETAILS. *JB
09/28/2004 · Wheels / tires
THIS IS RELATED TO THE DIAMLER CHRYSLER DODGE SPRINTER TIRE VALVE STEMS THAT I READ YOU ARE INVESTIGATING. I HAVE A 2002 FREIGHTLINER SPRINTER (SAME VAN AS THE DODGE MADE BY MERCEDES). MY VAN HAS THE 15"GOODYEAR CARGO TIRES. I'VE HAD PROBLEMS WITH BOTH REAR TIRES. OCCASIONALLY, THEY WOULD LOOSE 10-20 PSI PRESSURE. BOTH REAR TIRES HAVE HAD BLOW OUTS IN…
07/29/2004 · Brakes
THE PARKING BRAKE WORE OUT WHICH CAUSED THE CALIPERS AND CABLE TO FREEZE. PRIOR TO THIS INCIDENT THE PARKING BRAKES WERE HAVING A LOT OF FAILURES. MANUFACTURER AND DEALERSHIP WERE NOT PROVIDING ANY ASSISTANCE ON THIS ISSUE. *AK