2004 Ford Windstar recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2004 Ford Windstar owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Suspension (9), Transmission / drivetrain (7), Vehicle Speed Control (4), Engine (4), Electrical system (3).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
04/27/2019 · Vehicle Speed Control
INTERMITTEN THE SPEEDOMETOR DOES NOT WORK AT ALL OR DOES NOT SHOW THE CORRECT SPEED, OVER DRIVE LIGHT BLINK CONSTANTLY, CRUISE DOES NOT WORK AT LL. HAPPEN IN CITY AND HIGHWAY. HITTING A BUMP SOMETIME CORRECT SPEEDOMETER OR DRIVING ON HIGHWAY THIS CONTNUES TO HAPPEN ON A DAILY BASES
10/18/2016 · Electrical system
TL* THE CONTACT OWNS A 2004 FORD WINDSTAR. THE CONTACT STATED THAT THE WARNING LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
01/05/2016 · Engine · fire
TL* THE CONTACT OWNED A 2004 FORD WINDSTAR. THE CONTACT STATED THAT THE ENGINE CAUGHT ON FIRE. THE CONTACT STATED THAT THE FAILURE OCCURRED AFTER THE VEHICLE RECEIVED ROUTINE MAINTENANCE WHERE THE BATTERY, THE WATER PUMP, AND THE ENGINE BELT WERE REPLACED. THE FIRE DEPARTMENT WAS PRESENT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS DES…
05/07/2015 · Suspension
TL* THE CONTACT OWNS A 2004 FORD WINDSTAR. THE CONTACT STATED THAT THE FRONT AXLE FRACTURED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 12V194000 (SUSPENSION). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 169,784. THE VIN WAS NOT AVAILABLE. THE CONSUMER STATED THERE…
12/29/2014 · Suspension
TL* THE CONTACT OWNS A 2004 FORD WINDSTAR. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30-35 MPH, THERE WAS A LOUD ABNORMAL NOISE COMING FROM REAR DRIVER SIDE OF THE VEHICLE. THE CONTACT DISCOVERED THAT THE REAR DRIVER SIDE AXLE DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE AXLE NEEDED TO BE REPLACED…
04/23/2014 · Vehicle Speed Control
TL* THE CONTACT OWNS A 2004 FORD WINDSTAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE STALLED AS THE ELECTRONIC THROTTLE CONTROL WARNING LAMP ILLUMINATED. THE VEHICLE RESTARTED ON THE FIRST ATTEMPT AND RESUMED NORMALLY. THE FAILURE RECURRED ON SEVEN SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNABL…
07/23/2013 · Suspension
TL* THE CONTACT OWNS A 2004 FORD WINDSTAR. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, A CRUNCHING SOUND WAS HEARD FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
07/08/2013 · Suspension
RETURNED VAN TO DEALERSHIP, REAR END MAKING NOISE. PREVIOUS RECALL (AUGUST 2012) FIX TO REINFORCE REAR AXLE NOW SHOWS AXLE IS CRACKED. FORD SAYS THEY WILL NOT ENACT A REPAIR, AFTER NUMEROUS CALLS TO CUSTOMER SERVICE, THE REP STATED THE RECALL DEPARTMENT STATED THE FIX IS PERFORMING AND THE VEHICLE IS SAFE TO DRIVE REGARDING THE REAR AXLE. I ASKED THAT T…