1990 Ford Taurus recalls & complaints

Component: STRUCTURE:FRAME AND MEMBERS
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Notes: NOTE: THIS RECALL CAMPAIGN SUPERCEDES RECALL CAMPAIGN 93V-106. OWNER NOTIFICATION IS EXPECTED TO BEGIN JANUARY 18, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: WHEELS:HUBCAP/COVER
Summary: WHEELS MAY CONTAIN CRACKS THAT COULD PROPOGATE IN RAISED PORTION OF WHEEL CENTER.
Consequence: UNDER SEVERE DUTY, THIS COULD RESULT IN EVENTUALSEPARATION OF WHEEL RIM FROM CENTER WITH LOSS OF CONTROL AND POSSIBLY ACOLLISION.
Remedy: REPLACE WHEELS WITH WHEELS OF A REVISED DESIGN.
Notes: SYSTEM: STEEL WHEELS.VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH POLICE VEHICLE OPTION PACKAGEAND 14 X 5.5" HEAVY-DUTY STEEL WHEEL.

Component: SUSPENSION:FRONT:SHOCK ABSORBER
Summary: THE ARC WELDS ON THE SWAY BAR BRACKET, WHERE IT ATTACHES TO THE STRUT RESERVE TUBE, DID NOT FUSE PROPERLY.
Consequence: OVER TIME, A PORTION OF THE BRACKET CAN TEAR AWAY FROM THE STRUT, FALLING INTO AND PUNCTURING THE TIRE OR CAUSING DAMAGE TO THE WHEEL, WHICH COULD RESULT IN AN ACCIDENT.
Remedy: MONROE DEALERS WILL REPLACE THE STRUT FREE OF CHARGE.
Notes: EQUIPMENT DESCRIPTION: AFTERMARKET SHOCK ABSORBERS FOR 1986 - 1994 FORD TAURUS AND MERCURY SABLE PASSENGER CARS; PART 71780, 81780. IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT MONROE AT 1-800-521-6754. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: WHEELS
Summary: CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
Notes: SYSTEM: STRUCTURE: STORAGE COMPARTMENTS.VEHICLE DESCRIPTION: PASSENGER CARS (STATION WAGONS).NOTE: FORD WILL HAVE SUFFICIENT QUANTITIES OF THE NEW LATCH ASSEMBLIES AVAILABLETO BEGIN THE REPLACEMENT RECALL IN JULY, 1992. UNTIL THE LATCH ASSEMBLY ISREPLACED, FORD RECOMMENDS OWNERS LOCK THE STORAGE COMPARTMENT WHEN NOT IN USE.ALSO, FORD ADVISES THAT THE LATCH STRIKER CAN BE REMOVED TO DISABLE THE CURRENTLATCH UNTIL REVISED LATCH ASSEMBLIES ARE AVAILABLE.

Component: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Summary: THE RIGID MOUNTED SAFETY BELT BUCKLES ARE DEFECTIVE IN THREE WAYS. FIRST, A FASTENED SAFETY BELT BUCKLE WILL NOT UNLATCH WHEN THE RELEASE BUTTON IS DEPRESSED. THIS RESULTS FROM INTERFERENCE BETWEEN THE BUCKLE EJECTOR FINGER AND THE BUCKLE TONGUE WINDOW. THE SECOND DEFECT IS THE SAFETY BELT BUCKLE MAY NOT LATCH. THE THIRD POSSIBLE DEFECT IS THAT THE TONGUE MAY BE RETAINED BY THE BUCKLE, BUT IT MAY NOT BE LATCHED SUFFICIENTLY TO PROVIDE OCCUPANT PROTECTION.
Consequence: AN INSUFFICIENTLY LATCHED OR UNLATCHED SAFETY BELTINCREASES THE RISK OF INJURY TO SEAT OCCUPANTS IN THE EVENT OF A SUDDEN STOP ORACCIDENT. IF THE SAFETY BELT BUCKLE WILL NOT UNLATCH, IT WILL NOT ALLOW THEOCCUPANT TO GET OUT OF THE VEHICLE IN AN EMERGENCY SITUATION.
Remedy: FORD WILL REPLACE THE RIGID MOUNTED SAFETY BELT BUCKLES WITH END RELEASE SAFETY BELT BUCKLES DESIGNED TO PREVENT LATCH PROBLEMS.
Notes: SYSTEM: SAFETY BELT BUCKLE.VEHICLE DESCRIPTION: PASSENGER CARS AND UTILITY VEHICLES.NOTE: ONLY THE END RELEASE BUCKLES ON "RIGID" MOUNTINGS ARE SUSCEPTIBLE TO THISMALFUNCTION, THE WEB-MOUNTED FRONT CENTER END RELEASE BUCKLES AND THEWEB-MOUNTED REAR FACING THIRD SEAT END RELEASE BUCKLES IN TAURUS OR SABLEVEHICLES WILL NOT BE REPLACED. ALSO, THE WEB-MOUNTED FRONT CENTER BUCKLES INEXPLORER VEHICLES WILL NOT BE REPLACED.

Component: AIR BAGS:FRONTAL
Summary: THREADED INFLATOR COMPONENTS MAY HAVE BEEN DAMAGED DURING ASSEMBLY WHICH MAY ALLOW COMPONENTS TO SEPARATE WHEN INFLATOR RECEIVES A SIGNAL TO DEPLOY THE AIR BAG.
Consequence: INFLATOR COMPONENT SEPARATION ALLOWS HOT COMBUSTION GASES TO ESCAPE INTO THE PASSENGER COMPARTMENT WHICH COULD RESULT IN INJURIES TO VEHICLE OCCUPANTS.
Remedy: REPLACE AIR BAG MODULES CONTAINING POTENTIALLY DEFECTIVE INFLATORS.
Notes: NOTE: THIS CAMPAIGN WAS INITIATED BY TRW, INC., MANUFACTURER OF THE AIR BAG MODULE SYSTEM: AIR BAG MODULES. VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH DRIVER SIDE SUPPLEMENTAL AIRBAG MODULES.

Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
Summary: FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
Notes: SYSTEM: BRAKES.VEHICLE DESCRIPTION: PASSENGER VEHICLES SOLD OR REGISTERED IN THE FOLLOWING STATES: CT, IL, IN, ME, MA, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.

Component: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
Summary: AN INCORRECT TRANSISTOR MAY CAUSE AUTOLAMP SYSTEM LIGHT SENSOR MODULE MALFUNCTION.
Consequence: HEADLAMPS COULD TURN OFF WHILE VEHICLE IS BEING DRIVEN ORREMAIN ON AFTER VEHICLE IS PARKED. LOSS OF HEADLIGHTS WHILE DRIVING AT NIGHTCOULD BE HAZARDOUS TO THE DRIVER AND OTHER TRAFIFIC.
Remedy: REPLACE LIGHT SENSOR MODULES.
Notes: SYSTEM: AUTOLAMP HEADLAMP CONTROL.VEHICLE DESCRIPTION: PASSENGER CARS WITH AUTOLAMP HEADLAMP CONTROL SYSTEM.

12/14/2009 · Electrical system
HOW DO I GET FORD MOTOR COMPANY TO HONOR GENUINE NHTSA RECALLS ON A 1990 FORD TAURUS WAGON??? IT CURRENTLY HAS COMPLAINT # NHTSA 90E043001; NHTSA 98V323000; NHTSA 93V106002; NHTSA 91V34000. I CANNOT GET DEALERSHIP TO REPLACE AIR BAG MODULE DEFECT, SEAT BELT DEFECT OR CPU REPLACEMENT DEFECT. WHAT DO I DO TO GET SOME ACTION ON THESE ISSUES???? *TR

07/22/2009 · Body / structure
TL*THE CONTACT OWNS A 1990 FORD TAURUS. WHILE DRIVING APPROXIMATELY 15 MPH, THE CONTACT HEARD A LOUD NOISE UNDERNEATH THE VEHICLE. SUDDENLY, THE STEERING WHEEL LOCKED UP. THE DRIVER EXPERIENCED EXTREME DIFFICULTY STEERING THE VEHICLE, WHICH RESULTED IN GREATER EFFORT TO TURN THE STEERING WHEEL. THE DRIVER PULLED INTO A PARKING LOT AND ROADSIDE ASSISTANC…

04/06/2009 · Airbags
TL*THE CONTACT OWNS A 1990 FORD TAURUS. WHILE DRIVING LESS THAN 30 MPH, THE FRONT DRIVER'S SIDE AIR BAG DEPLOYED WITHOUT WARNING OR A CRASH OCCURRING. THE CONTACT SUSTAINED INJURIES TO HER ARMS, LACERATIONS ON HER FACE AND ARMS, AND A LARGE BURN ON HER LIP. THE MANUFACTURER SENT AN INSPECTOR TO INVESTIGATE THE AIR BAG FAILURE. THE FAILURE AND CURRENT MI…

08/07/2008 · Electrical system · fire
I HAD A LOOSE IGNITION ON MY 1990 FORD TAURUS IN WHICH I COULD REMOVE MY KEY WHILE IT WAS STILL RUNNING I HAD THIS CHANGED WHILE I WAS HAVING OTHER WORK DONE ON THE CAR AND LESS THEN A WEEK LATER I HAD A VERY EXPENSIVE PAPERWEIGHT BECAUSE AFTER THEY PLACED A NEW IGNITION INTO MY CAR IT CAUGHT FIRE WHILE I WAS DRIVING IT BURNING OUT ALL THE WIRING AND DESTR…

03/31/2008 · Body / structure
TL*THE CONTACT OWNS A 1990 FORD TAURUS SHO. WHILE MAKING A RIGHT TURN INTO A PARKING LOT, THE SUBFRAME BOLT FAILED AND THE VEHICLE DROPPED. THE ENGINE SHUT OFF AND THE VEHICLE HAD TO BE TOWED TO THE CONTACT'S RESIDENCE. THE DEALER AND MANUFACTURER STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 98V323000 (STRUCTURE:FRAME AND MEMBERS)…

07/28/2006 · Airbags
CHECK ENGINE LIGHTS CAME ON STAYED ON. AIR BAG LIGHT CAME ON FLASHES 9 TIMES PAUSES AND THEN FLASHES 9 TIMES REPEATS. CRUISE CONTROL STOPS WORKING. *JB

05/31/2005 · Seat belts
THE BELTS WERE REPLACED DUE TO RECALL CAMPAIGN# 92V113000 AT 88K MILES. AT 120K MILES, THE DRIVER SIDE LATCH MECHANISM BECAME STIFF, THEN THE OUTER SLEEVE HAD COME APART. THE SLEEVE WAS PLACED BACK INTO PLACE AND THE BELT WAS BACK FUNCTIONING PROPERLY. *AK *SC *JB

02/28/2005 · Vehicle Speed Control · crash
OWNER WAS DRIVING AND PULLED OUT OF A PARKING LOT AT APPROXIMATELY 5 MPH, APPLIED THE BRAKES, AND THE VEHICLE CONTINUED TO ACCELERATE. OWNER HAD TO AVOID SEVERAL POSSIBLE ACCIDENTS BY PUTTING THE VEHICLE IN PARK IN ORDER TO GET THE VEHICLE TO STOP. HOWEVER, OWNER'S VEHICLE DID HIT ANOTHER VEHICLE. OWNER CONTACTED THE MANUFACTURER, AND WAS INFORMED THAT THER…