1999 Ford F53 recalls & complaints

Component: VEHICLE SPEED CONTROL
Summary: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Notes: FORD RECALL NO. 05S28. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION;S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: VEHICLE SPEED CONTROL
Summary: VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.
Consequence: IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
Notes: A PRE-RELEASE WARNING LETTER THAT IDENTIFIED AN INTERIM FIX UNTIL THE PARTS FOR THE PERMANENT FIX BECAME AVAILABLE WAS MAILED TO OWNERS BEGINNING MARCH 27, 1999. A SECOND OWNER NOTIFICATION, IDENTIFYING THE PERMANENT FIX WAS MAILED TO OWNERS BEGINNING MAY 24, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

02/26/2008 · Vehicle Speed Control
TL*THE CONTACT OWNS A 1999 FORD F53. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL). THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THERE HAD BEEN NO FAILURE TO DATE. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE WAS 58,200. UPDATED 3/11/08 UPDATED 03/11/08 *TR

07/23/2007 · Suspension
I CONTINUE TO HAVE PROBLEMS WITH THE WHEELS ON MY FORD F53 CHASSIS MOTORHOME. FORD WILL NOT RESOLVE THE PROBLEM WHAT SO EVER EVEN WHEN THEY HAVE A TSB OUT ON THE PROBLEM! MY UNDERSTANDING IS THAT THE CENTER HOLE IN THE WHEEL WHICH IS USED TO CENTER THE WHEEL ON THE HUB IS TOO LARGE AND THE WHEEL CAN NOT BE PROPERLY CENTERED ON HUB. FORD SHOULD REPLACE THE…

12/08/2005 · Engine
FORD 1999 F-53 MOTORHOME CHASSIS -LOSS OF POWER IN A DRIVING RAINSTORM. WATER FOUND IN AIR INTAKE - LOWER BOWL. *JB

07/05/2005 · Engine
DT: CALLER SAID THERE WAS A RECALL ON V8 ENGINES, NOT ON V10. CALLER WAS HAVING THE SAME PROBLEM WITH HIS VEHICLE'S EXHAUST MANIFOLD AND STUDS. CALLER SAID STUDS BROKE AND EXHAUST WAS LEAKING INTO THE CAB OF VEHICLE. CALLER THOUGHT THE STUDS RUSTED. DEALER SAID THEY COULD NOT HELP HIM UNLESS CONSUMER PAID FOR IT. MANUFACTURER SAID CONSUMER WAS NOT H…

12/19/2003 · Unknown Or Other
WHATS THE USE OF HAVING TSB'S WITH NO INFORMATION? JUST WANT TO MAKE A DIME MORE? THIS SITE IS USELESS. WHAT DO YOU THINK PEOPLE ARE LOOKING FOR WHEN THEY SEARCH TSB'S? ANSWERS! YOU HAVE NONE! QUIT WASTING PEOPLES TIME AND MONEY.*AK

07/15/2002 · Suspension
WHILE DRIVING TRUCK SHAKES.*AK

01/07/2001 · Suspension
WHEELS CANNOT BE BALANCED TO PREVENT VIBRATION OF VEHICLE. DIFFERENTIAL WAS DEFECTIVE FROM FORD AND WAS REPLACED AFTER TWO ATTEMPTS TO FIX SAME. CHASSIS IS STILL VIBRATING AND UNUSABLE AS ONE REPAIR ATTEMPT WRAPPED THE GENERATER GAS LINE AROUND THE GENERATOR EXHAUST PIPE ( THIS REPAIR ATTEMPT WAS BY FLEETWOOD MOTORHOMES IN DECATUR, IND. ON A SECOND TRY TO F…

07/18/2000 · Engine
WHENEVER IT RAINS WATER GETS INSIDE OF ENGINE AIR FILTER ON THE MOTORHOME CHASSIS. THIS CAUSES ENGINE TO SHUTDOWN. WOULD STALL OUT WHEN STARTING. TSB #13079 ON CHASSIS. DEALER COULD NOT REPAIR PROBLEM AND GET WATER OUT OF ENGINE. *AK *ML