2003 Ford F Super Duty recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2003 Ford F Super Duty owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (13), Fuel system (6), Diesel (3), Electrical system (2), Wheels / tires (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
02/28/2018 · Equipment
THOR MOTORCOACH. CONSUMER WRITES IN REGARDS TO KIDDIE PORTABLE FIRE EXTINGUISHER SAFETY RECALL. *LD THE CONSUMER STATED THE VEHICLE WAS SOLD TO AN UNKNOWN PERSON(S);THEREFORE, THEY DID NOT RECEIVE THE RECALL NOTICE. *JS
09/18/2017 · Brakes
THE BRAKE PEDAL SINKS AT STOPS. I'VE HAD SERVICE TECHNICIANS CHECK THE SYSTEMS, TWO MASTERCYLINDERS HAVE BEEN INSTALLED THAT DID'NT CORRECT THE ISSUE. THEY HAVE DETERMINED THE ABS VALVE IS THE ISSUE AND WILL NOT FAIL ON A HARD BRAKE.. I DON'T THINK THIS IS A SAFE SITUATION AND AM WONDERING WHY THERE IS NOT A RECALL ON IT
04/30/2017 · Engine
MY TRUCK HAS 101K MILES ON IT AND IT JUST STARTED STALLING OUT WHILE DRIVING( ON STREETS AND HIGHWAYS), ALSO WHILE JUST IDLING IT STALLS(STATIONARY). I TOOK IT TO MY LOCAL FORD FOR THEM TO HOOK IT UP ON THEIR COMPUTER TO SEE WHAT THE PROBLEM IS. AFTER HOURS THERE AND IT STALLING OUT AND NOT RESTARTING THEY COULDN'T TELL WHAT WAS WRONG WITH IT AND CHARGED M…
01/20/2017 · Electrical system
TRUCK STALLS AND OR MISFIRES WHEN INTERMITTENT WIPERS ARE ON WHEN SITTING IN STOPPED POSITION TRUCK WILL STALL AND WHEN IN MOTION IT WILL MISFIRE AND STUMBLE ONLY WHEN WIPERS ARE ON AND NOT ANY OTHER TIME
09/18/2016 · Wheels / tires
F-350 CREW CAB 4X4, DUALLY TRUCK WITH FORD FACTORY ALUMINUM ALLOY WHEELS. THE RIGHT FRONT WHEEL STARTING LEAKING AIR AND WHEN CHECKED, A CRACK BEGINNING AT THE VALVE STEM WAS PROPAGATING TOWARD THE CENTER OF THE WHEEL AND CRACKS WERE ALSO DEVELOPING ALONG THE BASE OF THE SPOKES, CIRCUMSCRIBING SEVERAL SPOKES. TOOK THE LEFT SIDE FRONT WHEEL OFF AND OBSERVED…
04/08/2016 · Engine
MY TRUCK HAS SPIT OUT TWO SPARK PLUGS ON THE PASSENGER SIDE OF THE ENGINE. THESE PLUGS HAD TO BE REPAIRED WITH A HELL-COIL AND THIS IS A TEMPORARY FIX. IT COST ME $400 TO REPAIR BOTH. MY TRUCK HAS OVER 100,000 MILES AND SPIT OUT THE FIRST AT 120,000.
03/19/2016 · Engine
SPARK PLUG SHOOT OUT OF ENGINE. THIS IS THE 3RD TIME IT IS BECAUSE THERE IS ONLY 4 THREADS TO SCREW INTO THIS HAS HAPPENED TO THIS TRUCK TWO TIMES WHEN IT WAS YOUR WITH THE FACTORY PLUGS. AND NOW WITH OTHERS THAT WERE THAT WERE DO TO SPECS BY FORD. THIS IS AN EXPENSIVE FIX AND IT IS DANGEROUS TO PEOPLE THAT STICK THEIR HAND IT THERE WHEN THEY SEE A FLOPP…
08/23/2015 · Steering
I AM THE SECOND OWNER OF THIS TRUCK, IT HAD 30,000 MILES ON IT WHEN I BOUGHT IT FROM THE DEALER IN 02/2005. THERE IS NO FRONT END ALIGNMENT ISSUES WITH THIS TRUCK. WHEEL HUB BEARINGS FAILURES, FRONT AXLE, TRUCK HAD OVER 200,000 MILES BEFORE THE FIRST WHEEL HUB BEARING FAILURE, SINCE THEN I HAVE HAD TO REPLACE 7 WHEEL HUBS BEARING FAILURES ON MY (2003 FORD F…