2005 Ford F-250 Sd recalls & complaints

Component: STEERING
Summary: Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.
Consequence: If the steering locks, it can increase the risk of a crash.
Remedy: Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: EXTERIOR LIGHTING:TAIL LIGHTS
Summary: FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Notes: FORD'S SAFETY RECALL NO. 11C18. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: ELECTRICAL SYSTEM:WIRING
Summary: CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Notes: FORD RECALL NO. 05S34. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Summary: ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.
Consequence: THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE. IF THE FUEL LINE SEPARATES, AN OPERATOR MAY NOTICE A GASOLINE ODOR AND/OR FUEL ON THE GROUND, LOSS OF POWER, AND THE ENGINE WILL EVENTUALLY STALL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Notes: FORD RECALL NO. 05S33. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: EQUIPMENT
Summary: TRUXXX IS RECALLING 338 AFTERMARKET REPLACEMENT WELDED 3" LIFT BLOCKS FOR REAR SUSPENSIONS, PART NO. 206073, INCLUDED IN SUSPENSION KIT NOS. 108035 AND 108036, SOLD BETWEEN JULY 26, 2007 AND MARCH 4, 2008, FOR USE ON FORD MY 2005-2008 F-250 SUPERDUTY 4X4 LIGHT TRUCKS. COMPRESSIVE FORCES OF THE WELDED LIFT BLOCKS RESULTING FROM FORESEEABLE AND EXCESS VEHICLE PAYLOADS AS WELL AS OVER-TIGHTENING OF THE U-BOLTS DURING INSTALLATION MAY DISTORT THE BLOCKS, REDUCING THE INTENDED CLAMPING FORCE OF THE U-BOLTS.
Consequence: THIS COULD ALLOW POSSIBLE SHIFTING AND DAMAGE TO THE REAR DRIVE SHAFT AND AXLE.
Remedy: TRUXXX WILL NOTIFY CUSTOMERS/INSTALLERS AND WILL REPLACE AFFECTED WELDED LIFT BLOCKS WITH EITHER NON-WELDED ALUMINUM OR CAST IRON BLOCKS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT APRIL 16, 2008. OWNERS MAY CONTACT TRUXXX AT 1-800-381-8320.
Notes: TRUXXX RECALL NO. 08-01BLK. THIS RECALL ONLY PERTAINS TO AFTERMARKET SUSPENSION KITS AND HAS NOT RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON FORD MOTOR COMPANY VEHICLES. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

12/07/2018 · Engine
TL* THE CONTACT OWNS A 2005 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT R…

02/09/2018 · Steering
TL* THE CONTACT OWNS A 2005 FORD F-250 SD. WHILE DRIVING 60 MPH, THE STEERING WHEEL BECAME VERY LOOSE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THIS WAS AN ONGOING FAILURE WITH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND TO BILLINGSLEY FORD LINCOLN OF LAWTON (8209 NW QUANAH PARKER TRAILWAY BLDG. 1, LAWTON,…

11/07/2017 · Electrical system
WHEN STEPPING ON BRAKES WHILE DIRECTIONAL IS ON THE DIRECTIONALS STOP FUNCTIONING WHILE IN MOTION AND TURNING WHICH IS A SERIOUS SAFETY HAZARD IM WONDERING WHY NHTSA 11V352000 IS ALLOWING FORD TO ONLY REPAIR CERTAIN VINS ESPECIALLY WHEN MY YEAR MAKE AND MODEL ARE SPECIFIED IN THE SUMMARY.WITH THE SAME EXACT SYMPTOMS???

04/10/2017 · Brakes
ON SEVERAL OCCASIONS, MY F250, SUPER DUTY 6.0 DIESEL BECAME SLUGGISH AND GAS MILEAGE SUFFERED IMMENSELY. THEN, WITH ONLY 53,000 MILES, MY LEFT REAR DISK BRAKE CALIPER WAS DRAGGING AND STARTED SMOKING. AT MY COST AND ON THE LEFT REAR, I HAD FORD REPLACE THE CALIPER, PADS, BRAKE LINE AND RESURFACE THE ROTORS. ALSO, THE RIGHT REAR ROTOR WAS RESURFACED. AT 54,0…

08/10/2016 · Wheels / tires
TIRE BEGAN TO SHIMMY, PULLED OVER FOUND NOTHING WRONG, 25 MILES LATER TIRE BLEW AT HIGHWAY SPEED CAUSING LOSE OF CONTROL. TIRE BELTS DID EXTENSIVE DAMAGE TO VEHICLE. SAME TIRE AS NHTSA RECALL NUMBER 15T-061 BUT MANUFACTURED 4 MONTHS PRIOR TO EARLIEST RECALL PRODUCTION DATE.

12/30/2015 · Fuel system
TL* THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FICM FUEL INJECTION CONTROL MODULE (FICM) HARNESS NEEDED TO BE REPLACED. THE VEHICLE…

10/19/2015 · Electrical system
TL* THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE DID NOT RESTART AND WAS PUSHED TO THE RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE DEALER INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA C…

08/26/2015 · Steering
WHILE DRIVING HOME FROM WORK, JUST LEAVING TOWN I HIT 50 MPH AND THE TRUCK STARTS TO WOBBLE FROM SIDE TO SIDE AND VIBRATE TILL I SLOW DOWN TO UNDER 40 MPH. I GOT THE NOTICE FROM FORD TELLING ME IT ALL HAD TO DO WITH TIRE PRESSURE. I INFLATED THE TIRES TO THE REQUIRED PRESSURE AND IT ONLY MADE THINGS WORSE. I HAVE CONTACTED THEM THE FIRST TIME THIS HAPPENE…