1998 Ford E-150 recalls & complaints

Component: VEHICLE SPEED CONTROL
Summary: FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Notes: FORD'S RECALL CAMPAIGN NUMBER IS 09S09. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: VEHICLE SPEED CONTROL
Summary: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Notes: FORD RECALL NO. 05S28. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION;S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Summary: VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35 GALLON MID-SHIP FUEL TANK COULD DEVELOP A CRACK WHERE IT CONTACTS THE FRAME CROSS MEMBER. IF THE FUEL TANK CRACKS, FUEL LEAKAGE COULD OCCUR.
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND, IF CRACKED, WILL REPLACE THE TANK. INSULATOR PADS WILL BE INSTALLED ON ALL VEHICLES TO REDUCE THE STRESS LEVELS IN THE FUEL TANK. OWNER NOTIFICATION BEGAN APRIL 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Notes: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: VEHICLE SPEED CONTROL:CRUISE CONTROL
Summary: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Notes: FORD RECALL NO. 08S01. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

04/10/2017 · Fuel system
TL* THE CONTACT OWNS A 1998 FORD E-150. WHILE THE CONTACT WAS FILLING UP THE FUEL TANK WITH FUEL, THE FUEL LEAKED OUT. THE SERVICE ENGINE WARNING INDICATOR ILLUMINATED, INDICATING A FUEL LEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE MIDSHIP FUEL TANK DEVELOPED A CRACK WHERE IT CONTACTED THE FRAME CROSS MEMBER AND NEE…

02/04/2015 · Equipment · crash
TL* THE CONTACT OWNED A 1998 FORD E-150 EQUIPPED WITH A CCI AIRTOUCH PNEUMATIC GAS/BRAKE. THE MODEL WAS UNKNOWN. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE BEGAN TO ACCELERATE WITHOUT CAUSE OR WARNING. THE FAILURE CAUSED A CRASH WITH ANOTHER VEHICLE, TREES, AND A STREET LAMP. THE CONTACT ATTEMPTED TO BRAKE, BUT THE VEHICLE CONTINUED. THE VEHICLE WAS DE…

07/07/2014 · Wheels / tires
LEFT FRONT TIRE (MICHELIN P235/75R15 LTX M/S2) SEPARATION AT 25 MPH. ALSO, NOTICEABLE STRESS CRACKS ON THE SIDEWALL OF THE TIRE. TIRES BOUGHT 01/2010; WITH 7/32 TREAD REMAINING. REFERENCE 13T012000. *JS

11/14/2012 · Fuel system
TL* THE CONTACT OWNS A 1998 FORD E-150. THE CONTACT STATED THAT AFTER REFUELING, FUEL SPEWED OUT OF THE FILLER NECK AND ONTO THE GROUND. THE VEHICLE WAS TAKEN TO THE DEALER TO BE INSPECTED. THE TECHNICIAN DIAGNOSED THAT THE FUEL TANK FAILED DUE TO CORROSION. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 80,750.

09/14/2011 · Fuel system
TL* THE CONTACT OWNS A 1998 FORD E-150. THE CONTACT STATED THE FUEL TANK STRAPS FRACTURED. THE CONTACT STATED THAT THE FUEL TANK AND STRAPS WERE THE SAME AS THE ONES UTILIZED ON THE 1998-2003 FORD F-150, IN WHICH WAS RECALLED FOR THE SAME FAILURE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE FAILURE MILEAGE WAS 250,000.

08/01/2011 · Seat belts · crash
TL* THE CONTACT OWNS A 1998 FORD E-150. WHILE AT A STOP SIGN THE CONTACT WAS REAR ENDED BY A VEHICLE DRIVING APPROXIMATELY 35 MPH. A POLICE REPORT WAS FILED. THE VEHICLE WAS DRIVEN AWAY FROM THE SCENE WITH DAMAGE TO THE REAR BUMPER AND FRAME. THE CONTACT SUFFERED NECK PAIN AND WAS SEEN BY A DOCTOR AT THE HOSPITAL. A CAT SCAN WAS PERFORMED BUT THERE WAS NO D…

05/16/2011 · Fuel system
98 FORD E-150 / SAFETY RECALL-01S14 I CONTACTED CHALMERS FORD DEALER ([XXX]) SANTA FE,NM 473-3673 / FORD CUSTOMER SERVICE([XXX]) 1-800-392-3673 MY VEHICLE EXHIBITS EXACTLY THE SAME SYMPTOMS AS RECALL AND WAS TOLD I WAS NOT ON THE LIST AND NOTHING COULD BE DONE-I DISCOVERED THE LEAK WHEN I WAS PUMPING GAS INTO THE GAS TANK AND A HUGE PUDDLE OF GAS WAS OBSE…

12/31/2009 · Engine
06-03-2007 RIGHT DOOR HANDLE (OUTSIDE PART) BROKE AND I COULD NOT GET INTO MY VAN. NO ABUSE ON MY PART. I HAD THE DOOR HANDLE REPLACED BY FORD DEALERSHIP AT MY EXPENSE ($125.00). 03-03-2008 LEFT DOOR HANDLE (OUTSIDE PART) BROKE WHEN I PULLED THE HANDLE. I NOW HAVE TO GET INTO MY VAN BY THE PASSENGER SIDE, AND CRAWL OVER TO THE DRIVERS SIDE. THIS IS AWF…