2004 Dodge Sprinter recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2004 Dodge Sprinter owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Wheels / tires (11), Engine (10), Transmission / drivetrain (4), Electrical system (4), Fuel system (3).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
02/04/2020 · Fuel system
UPON COMPLETION OF THE T21 RECALL, THE CHECK ENGINE LIGHT (ERROR CODE U0423) CAME ON. THE INSTRUMENT CLUSTER LIGHT CONTINUED TO ILLUMINATE AFTER THE VEHICLE'S IGNITION WAS OFF, DRAINING THE BATTERY.
07/05/2018 · Engine
TL* THE CONTACT OWNS A 2004 DODGE SPRINTER. THE CONTACT STATED THAT THE VEHICLE CONSISTENTLY MISFIRED. THE DODGE MANUFACTURER INCLUDED THE VEHICLE IN ITS T21 EMISSIONS RECALL FOR THE ENGINE CONTROL UNIT; HOWEVER, THE TOOLS, AN AVAILABLE TECHNICIAN, AND THE PART WAS NOT AVAILABLE TO SCHEDULE THE REPAIR APPOINTMENT. THE FOLLOWING DEALERS WERE CONTACTED: ED VO…
11/29/2017 · Unknown Or Other
I USED YOUR ONLINE VIN CHECKER TO SEE IF MY CAR HAS A RECALL AND IT SAID NO RECALLS, AND REQUEST INVALID BUT I KNOW I ENTERED THE CORRECT VIN AND YOU GAVE ME MY VEHICLE YEAR AND MODEL INFORMATION.
03/02/2015 · Wheels / tires
FOUR P225/75R15XL SCORPION STR TIRES PURCHASED & INSTALLED 8-5-10 AT EVANS TIRE &SERVICE CENTER 1530 GARNET AVE. SAN DIEGO CA 92109 ONTO 2004 DODGE SPRINTER 2500, MILEAGE 28274. ON 2-28-2015 MILEAGE APPROX.43125MI. : PASSERBY REPORTED LEFT REAR TIRE APPEARED VERY LOW ON AIR; DRIVER IMMEDIATELY PRESENTEDVAN TO SAME SHOP WHERE EMPLOYEE REFUSED TO FIL…
07/13/2014 · Body / structure
THE SLIDING DOOR WHICH IS THE ONLY EGRESS FOR PASSENGERS IN THE BACK OF THE VAN WILL NOT OPEN. I HAVE HAD IT FIXED 4 TIMES AND IT CONTINUOUSLY FAILS. I HAVE TALKED TO OTHER SPRINTER OWNERS AND THEY HAVE THE SAME PROBLEM. SHOULD THERE BE AN INCIDENT THAT REQUIRED THE QUICK EVACUATION OF THE VAN BY PASSENGERS IN THE REAR OF THE VAN THEY COULD BE VERY SERIO…
11/09/2012 · Engine
DRIVING AT FREEWAY SPEED THE VEHICLE LOSSES POWER AND THE SPEED DECREASES TO ABOUT 40 MPH. I CAN PULL OVER AND TURN OF THE MOTOR FOR ABOUT 10 SECONDS AND START UP AND THE VEHICLE WILL RESET AND RUN FINE UNTIL IT DOES IT AGAIN RANDOMLY. THIS IS VERY DANGEROUS ESPECIALLY WHEN YOU ARE IN THE LEFT HAND LANE AND YOU ARE TRYING TO GET TO A SAFE PLACE TO PULL OVE…
02/25/2010 · Brakes
2004 DODGE SPRINTER - THE BRAKING SYSTEM STIFFENS UP (POWER BRAKE) IF I PUSH THE PEDAL HARD ESPECIALLY WHEN I BACK UP THE VEHICLE. IT'S LIKE THE BOOSTER HAS FROZEN SOLID AND THE BRAKE PEDAL CAN'T TRAVEL ALL THE WAY DOWN. IF I LET THE VEHICLE SIT FOR A WHILE (1 HR) IT WILL GET BACK TO NORMAL. THIS IS A REPEAT INCIDENT AND STARTED IN THE FIRST YEAR BUT I DID…
10/22/2009 · Transmission / drivetrain
IN MAY OF 2005 I PURCHASED A NEW DODGE (MERCEDES BENZ) SPRINTER 2500 PASSENGER VAN. WITHIN THE FIRST 3 MONTHS AND 7,500 MILES OF DATE OF PURCHASE THE VEHICLE BEGAN TO SHOW SIGNS OF PREMATURE RUSTING AND LEAKAGE OVER THE ENTIRE VEHICLE. I PURSUED REMEDY THRU ALL AUTHORIZED SPRINTER DEALERSHIPS ADHERING TO CHRYSLER PROTOCOLS AND RECOMMENDATIONS. NO REMEDY WA…