2002 Dodge RAM Quad Cab recalls & complaints

Component: EXTERIOR LIGHTING
Summary: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER. IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT. THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: VISIBILITY:WINDSHIELD WIPER/WASHER
Summary: CHRYSLER IS RECALLING 1,364 WINDSHIELD WIPER MODULES, P/N 55077098AJ, SOLD DURING THE 2008 AND 2009 CALENDAR YEAR FOR USE AS AFTERMARKET REPLACEMENT EQUIPMENT ON MY 2002-2009 DODGE RAM PICKUP TRUCKS. THESE WIPER MODULE ASSEMBLIES MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD RESULT IN PARTIAL OR COMPLETE LOSS OF WINDSHIELD WIPER CAPABILITY.
Consequence: WHEN THE WIPER SYSTEM FAILS, THE OPERATOR WILL HAVE REDUCED VISIBILITY WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MODULE ASSEMBLIES WITH VENTED WIPER MOTOR HOUSINGS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 28, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Notes: CHRYSLER'S RECALL NO. J11. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Component: EQUIPMENT:ELECTRICAL
Summary: CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Remedy: ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: EXTERIOR LIGHTING
Summary: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Summary: ON CERTAIN VAN AND WAGON VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), AFTERMARKET BATTERIES MAY LEAK ELECTROLYTE ONTO THE ABS CONTROL MODULE CONNECTOR, WHICH CAN COMPROMISE SEALING INTEGRITY OF THE CONNECTOR.
Consequence: THIS MAY ALLOW DEVELOPMENT OF A SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE ABS CONTROL MODULE CONNECTOR FOR ELECTROLYTE DAMAGE AND REPLACE THE CONNECTOR AS NECESSARY. THE RECALL WILL BEGIN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Notes: DAIMLERCHRYSLER RECALL NO. D20. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: POWER TRAIN:AXLE ASSEMBLY
Summary: ON CERTAIN 4X4 PICKUP TRUCKS, THE REAR AXLE FLANGE WELD TO THE AXLE TUBE COULD FATIGUE AND ALLOW THE BRAKE CALIPER ASSEMBLY TO ROTATE.
Consequence: DURING ROTATION, THE BRAKE LINE COULD SEPARATE FROM THE CALIPER RESULTING IN A BRAKE FLUID LOSS IN THE REAR BRAKE HYDRAULIC SYSTEM.
Remedy: DEALERS WILL INSTALL REAR BRAKE CALIPER REINFORCEMENTS ON THE REAR AXLE ASSEMBLIES. OWNER NOTIFICATION BEGAN DECEMBER 9, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Notes: DAIMLERCHRYSLER RECALL NO. B20. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

12/26/2019 · Body / structure
THE PLASTICS USED IN THE 2002 DODGE RAM INTERIOR ARE A SAFETY ISSUE. THERE IS WIDESPREAD EVIDENCE ACROSS THE INTERNET SHOWING THE DASH BREAKING APART LIKE MINE. IT IS STRUCTURALLY UNSOUND AND DODGE SHOULD FIND A SAFE SOLUTION. IF I GOT INTO AN ACCIDENT SHARP SHARDS OF DASH FLYING AROUND IS MORE LIKELY TO CAUSE INJURY THAN THE IMPACT OF THE CRASH.

06/02/2019 · Transmission / drivetrain
BOUGHT TRUCK IN 2009. DRIVE A COUPLE TIMES A WEEK. TRANSMISSION HAS WENT OUT 5 TIMES NOW INCLUDING THIS MORNING. WAS TOLD BY A COWORKER THAT THERES AB ISSUE WITH THE DODGERS NOT CIRCULATING FLUID WHEN IDLING IN GEAR.??? EITHER WAY THIS WILL BE THE 5TH TIME IN 10 YEARS TAKING IT TO GET REBUILT!!!! WHICH HAS BEEN 2,500.00 TO 4,000.00 EACH TIME!!! REALLY BOUT…

05/27/2018 · Transmission / drivetrain
REAR END LOCKED UP GOING DOWN HIGHWAY AT APPROXIMATELY 45 MPH, SENT ME SLIDING INTO THE SLOW LANE AND THEN OFF OF THE HIGHWAY INTO A DRIVEWAY COMING TO A HALTING STOP WITH MY TAILGATE WAS STILL PARTIALLY IN A HEAVILY TRAVELED HIGHWAY. THE DRIVESHAFT ALSO DROPPED DOWN AND EVENTUALLY CAME COMPLETELY OFF AND I HAD TO CALL A ROLL BACK TO COME GET TRUCK. I HAVE…

03/16/2018 · Body / structure
CRAKED DASH, SHARP METAL AND SHARP BROKEN CHUNKS OF PLASTIC THAT USED TO BE A DASHBOARD. NOT SAFE TO DRIVE THIS WAY! THE PARTS IF AVAILABLE ARE EXSPENSIVE, WHY IS THIS NOT RECALLED REPLACING USING BETTER SAFER PRODUCTS.

03/13/2018 · Unknown Or Other
I HAVE A 2002 DODGE RAM 1500 P/U TRUCK. I'M AWARE THAT IT'S OUT OF WARRANTY. I PLAN TO KEEP THIS TRUCK UNTIL I DIE. THE DASHBOARD IS COMPLETELY DAMAGED. I NOW HAVE A DASH COVER OVER IT. AND IT'S SEEM TO BE FALLING IN AS WELL. PLEASE CONSIDER REPLACING MY DASH SINCE IT'S THE WRONG MATERIAL ON ALL 3RD GENS WERE MADE OUT OF POLYVINYL CHLORIDE. AS TIME PASSES T…

01/24/2018 · Visibility (wipers / glass)
BLOWS HEAT ONLY ON PASSENGER SIDE VENTS. BLOWS COOL AIR ON DRIVERS SIDE.

12/12/2017 · Visibility (wipers / glass)
TL* THE CONTACT OWNS A 2002 DODGE RAM QUAD CAB. THE CONTACT STATED THAT THE DASHBOARD WAS FRACTURED ALONG THE AIR CONDITIONER AND HEATER VENT. THE CONTACT WAS CONCERNED THAT THE FRONT PASSENGER AIR BAG COULD INADVERTENTLY DEPLOY BECAUSE OF THE FRACTURE. THE CONTACT STATED THAT THE AIR CONDITIONER AND HEATER VENT WERE INOPERABLE ON THE LOWER SETTINGS DUE TO…

02/13/2015 · Wheels / tires
MICHELIN LATITUDE TIRES P265/70 R17 BOUGHT SEPT. 2011 FROM COSTCO IN INGLEWOOD CALIF. THE TREAD SURFACE IS PEELING FROM THE TIRE. THERE ARE SMALL CRATER LIKE AREAS WHERE THE TREAD HAS CRUMBLED AWAY. THE LATITUDE TIRE WAS ADVERTISED AS; "LATITUDE TOUR TIRES USE A SILICA-BASED TREAD COMPOUND MOLDED INTO A SYMMETRIC TREAD DESIGN". I WENT TO COSTCO TO SEE IF TH…