2002 Dodge RAM 2500 recalls & complaints

Component: VISIBILITY:GLASS, SIDE/REAR
Summary: CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
Remedy: SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Notes: THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: ENGINE AND ENGINE COOLING
Summary: CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999, THROUGH SEPTEMBER 23, 2004. THESE ASSEMBLIES WERE MANUFACTURED AS REPLACEMENT EQUIPMENT FOR CERTAIN DODGE PICKUP TRUCKS AND SUVS. A SMALL PIECE OF MATERIAL FROM THE TUBE WALL COULD BE SUCKED INTO THE ENGINE THROTTLE BODY, WHICH COULD CAUSE THE THROTTLE TO BECOME JAMMED IN THE OPEN POSITION.
Consequence: A JAMMED OPEN THROTTLE COULD CAUSE UNINTENDED ACCELERATION OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH OR INCREASED STOPING DISTANCES WHEN BRAKING.
Remedy: K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.
Notes: THIS RECALL ONLY PERTAINS TO REPLACEMENT K&N FUEL PERFORMANCE KITS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DODGE VEHICLES MANUFACTURED BY DAIMLERCHRYSLER. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

04/13/2021 · Steering
I PURCHASED A 2003 DODGE RAM 2500 5.7 V8 4WD. MY STEERING HAS GOTTEN REALLY LOOSE OVER THE LAST WEEK. I BROUGHT IT IN TO DEALERSHIP FOR A PREVIOUS RECALL. AND THE TECHNICIAN TOLD ME THAT MY STEERING GEAR WAS GOING OUT AND THAT IT SHOULD NOT BE BAD.

07/18/2020 · Vehicle Speed Control
DRIVING DOWN THE ROAD WONT ACCELATE THEN LOOSE POWER , THEN AFEW A FEW MINUTES DRIVES GREAT THEN NEVER KNOW WHEN IT WILL NOT ACCELATE DRANGE LOSING POWER LIKE THAT

09/16/2019 · Unknown Or Other
DASHBOARD HAS STARTED CRACKING AND SHARP PIECES OF PLASTIC HAVE BECOME LOOSE CREATING A POTENTIAL FOR THEM TO BECOME PROJECTILES IN THE EVENT OF AN ACCIDENT. SEEMS MOST OF THE PLASTIC TRIM PIECES ARE BRITTLE INSIDE THE VEHICLES PASSENGER CABIN.

06/11/2019 · Vehicle Speed Control
CRUISE CONTROL WAS ON AND USED ACCELERATOR PETAL TO ACCELERATE, ENGINE RPM WENT TO MAX AND SPEED INCREASED 20 MPH AND CONTINUED. TAPPED ACCERATOR AND TURNED OF SPEED CONTROL, SPEED CONTINUED. PUT GEAR IN NEUTRAL AND WORKED MY WAY TO ROAD SIDE. FOUND THAT CABLE FRAYED AND JAMMED AT HIGH RPM. DISCONNECTED CABLE AND HAVE NOT FOUND REPLACEMENT CABLE YET. PAR…

02/05/2018 · Electrical system · crash
THE PLASTIC DASHBOARD AND RELATED UNDERPINNINGS AND SUPORT STRUCTURE FOR EVERYTHING FROM PASSENGER AIRBAG,RADIO, CLIMATE CONTROL AND VENTS, HEADLIGHT, MIRROR DEFROSTER, GAUGE POD, ONBOARD DIAGNOSTIC PLUG, ETC. BEGAN DISINTEGRATING IN LARGE SHARP PIECES WHILE DRIVING. THESE PIECES CUT WIRING AND FLES FOR ANYTHING AND EVERYTHING AND ARE DISTRACTING AND DANG…

12/31/2017 · Unknown Or Other
THE DASH HAS CRACKED INTO SEVERAL PIECES THAT ARE NOW A HAZZARD OF FLYING SHARDS IN CASE OF AN ACCIDENT. ALSO THERE ARE HOLES INT THE DASH WHERE THE PIECES HAVE BROKEN OUT THAT CAN ALLOW DEBRIS TO FALL INSIDE THE DASH THAT CAN CAUSE FIRES OR ELECTRICAL SHORTS.

11/30/2017 · Steering
I AM HEARING A POPPING SOUND WHEN TURNING THE STEERING WHEEL, PLAY IN STEERING, TRUCK IS WOBBLING ALL OVER THE PLACE WHEN DRIVING ON UNEVEN ROADS, HISSING SOUND COMING FROM FRONT END WHEN ACCELERATING. PLAY IN STEERING GEAR BOX. THE CLICKING POPPING SOUND I HEAR WHEN TURNING STEERING WHEEL IS WHEN DRIVING OR NOT MOVING. I HAVE HAD THIS TRUCK PULL FAR RIGH…

09/12/2017 · Suspension
DODGE RAM "DEATH WOBBLE" OR SHIMMY PHENOMENON, WHILE IN MOTION AND ENCOUNTERING HIGHWAY ROAD SURFACE CHANGES.