1995 Dodge Caravan recalls & complaints

Component: EQUIPMENT
Summary: AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS.
Consequence: IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.
Remedy: AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18230 AND DATE CODE 0237, 0249, 0251, OR 0304. REPLACEMENT FUEL FILTERS FOR 2001-2004 CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 28871 AND DATE CODE 0249. THESE PART NUMBERS AND DATE CODES APPEAR ON THE GOLD-TONE FILTER. DISTRIBUTORS AND RETAILERS WILL BE NOTIFIED TO ISOLATE AND RETURN AFFECTED INVENTORY. OWNERS WHO HAVE HAD THE FUEL FILTER SERVICED ON ONE OF THE APPLICABLE VEHICLES AFTER SEPTEMBER 17, 2002 SHOULD RETURN THEIR VEHICLE TO THE SERVICE FACILITY TO BE INSPECTED TO SEE IF THE FUEL FILTER THAT WAS INSTALLED IS ONE THAT IS INVOLVED IN THE RECALL. IF SO, THE OWNERS SHOULD HAVE THE FILTER REPLACED. TO RECEIVE A FULL REFUND PLUS THE COST OF POSTAGE, OWNERS SHOULD CUT THE CONNECTORS FROM THE HOSES, RINSE THE CONNECTORS AND RETURN THEM TOGETHER WITH PROOF OF THE AMOUNT PAID FOR THE REPLACEMENT PART AND LABOR, TO INTERCONTINENTAL AT INTERCONTINENTAL AUTO PARTS, INC., P.O. BOX 861, MAHWAH, NJ 07430, ATTN: FUEL FILTER RECALL. INTERCONTINENTAL WILL MAIL A FULL REFUND TO THE OWNER.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER, AND DODGE CARAVAN MINIVANS OR ANY OTHER PRODUCTS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION. CONSUMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
Summary: VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER MINIVANS WITH REMOTE RELEASE. THIS IS NOT A SAFETY RECALL. THERE HAS BEEN NO DETERMINATION THAT A SAFETY DEFECT EXISTS WITH THE MINIVAN LATCHES. CHRYSLER IS CONDUCTING A SERVICE CAMPAIGN TO REPLACE THE LIFTGATE LATCH ASSEMBLY OF THE AFFECTED MINIVANS. IN A COLLISION, THE REAR LIFTGATE LATCH ASSEMBLY COULD OPEN.
Consequence: IF THE LIFTGATE LATCH OPENS, OCCUPANTS CAN BE EJECTED RESULTING IN SIGNIFICANTLY INCREASED RISK OF INJURY OR DEATH.
Remedy: CHRYSLER WILL REPLACE THE LIFTGATE LATCH WITH A NEW STRONGER LATCH ASSEMBLY WITHOUT CHARGE. CHRYSLER BEGAN NOTIFYING OWNERS DURING DECEMBER 1995.
Notes: THIS IS NOT A SAFETY RECALL. THERE HAS BEEN NO DETERMINATION THAT A SAFETY DEFECT EXISTS WITH THE MINIVAN LATCHES. HOWEVER, CHRYSLER HAS DECIDED TO PROVIDE A STRONGER LATCH WITHOUT CHARGE. OWNERS CAN CONTACT CHRYSLER AT 1-800-MINIVAN (1-800-646-4826).

Component: LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
Summary: VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER MINIVANS WITHOUT REMOTE RELEASE. THIS IS NOT A SAFETY RECALL. THERE HAS BEEN NO DETERMINATION THAT A SAFETY DEFECT EXISTS WITH THE MINIVAN LATCHES. CHRYSLER IS CONDUCTING A SERVICE CAMPAIGN TO REPLACE THE LIFTGATE LATCH ASSEMBLY OF THE AFFECTED MINIVANS. IN A COLLISION, THE REAR LIFTGATE LATCH ASSEMBLY COULD OPEN.
Consequence: IF THE LIFTGATE LATCH OPENS, OCCUPANTS CAN BE EJECTED RESULTING IN SIGNIFICANTLY INCREASED RISK OF INJURY OR DEATH.
Remedy: CHRYSLER DEALERS WILL REPLACE THE LIFTGATE LATCH WITH A NEW STRONGER LATCH ASSEMBLY WITHOUT CHARGE. CHRYSLER BEGAN NOTIFYING OWNERS OF THESE VEHICLES BEGINNING SEPTEMBER 1995.
Notes: THIS IS NOT A SAFETY RECALL. THERE HAS BEEN NO DETERMINATION THAT A SAFETY DEFECT EXISTS WITH THE MINIVAN LATCHES. HOWEVER, CHRYSLER HAS DECIDED TO PROVIDE A STRONGER LATCH WITHOUT CHARGE. OWNERS CAN CONTACT CHRYSLER AT 1-800-MINIVAN (1-800-646-4826).

Component: AIR BAGS
Summary: VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Notes: OWNER NOTIFICATION BEGAN AUGUST 2, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHRYSLER AT 1-800-992-1997. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

04/14/2017 · Body / structure
FRONT DOOR HINGE MOUNT SHEET METAL TEARS OR CRACKS. DOOR LATCHES FAIL DO TO SAGGING DOORS. SHEET METAL HAS CRACKED GOING BACK INTO THE FIRE WALL BULKHEAD. DOORS CAN FLY OPEN ON OUTSIDE TURNS WITH OUT WARNING, POTENTIALLY DISLODGING PASSENGETS.

02/18/2015 · Electrical system
IM DRIVING ALONG AND MY GAUGES START GOING ON AND OFF AND FLICKERING .THEN AFTER AWHILE THEY COME BACK ON THEN START BACK UP GOING OFF AND ON. *TR

06/08/2011 · Electrical system
INTERMITTENT ELECTRIC DOOR LOCK FAILURE. HAD THE MAIN CONTROL PANEL ON THE DRIVER'S DOOR REPLACED SHORTLY AFTER DISCOVERING THE PROBLEM AT A COST OF ABOUT $175 PART AND LABOR--CHANGED NOTHING. RESEARCHED ON LINE AND FOUND THAT REMOVING NEGATIVE BATTERY CABLE FROM THE NEGATIVE POST FOR ABOUT 30 MINUTES TEMPORARILY FIXES THE DOOR LOCKS FOR ABOUT 2-3 WEEKS. I…

12/28/2009 · Fuel system
BAD FUEL LEAK FROM FUEL RAIL. HUGE POTENTIAL FOR FIRE. *TR

09/29/2009 · Airbags
BOUGHT A NEW 1995 DODGE CARAVAN IN MAY OF SAME YEAR. SHORT TIME LATER A LETTER NOTIFYING US OF REAR LATCH DOOR COMING OPEN AT IMPACT----TOOK CARE OF IT. ABOUT 3 YEARS AFTER THAT A 20 AMP FUSE IN POSITION #20 KEPT BLOWING, AIR BAG LIGHT WOULD COME ON AND REAR WINDOW WIPER WOULD GO OUT. A SHORT TIME AGO WHILE LOOKING UP PARTS FOR ANOTHER VEHICLE AT ADVANCE AU…

12/21/2008 · Seats · crash
DODGE CARAVAN SE 1995 MODEL HAS DEFECTIVE AND UNSAFE DRIVER SEAT BACK RESTS. MY DODGE CARAVAN SE 1995 MODEL WAS REAR ENDED BY A SPEEDING TOYOTA COROLLA. THE DODGE WAS GOING BELOW 10 MPH DUE TO CONSTRUCTION AHEAD ON THE ROAD. THE COROLLA WAS SPEEDING OVER 65MPH(ABOUT 75MPH). THE DODGE CARAVAN DRIVER SEAT BACK REST FELL BACKWARD. I ABSOLUTELY LOST CONT…

06/30/2006 · Brakes
DT*: THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE TRANSMISSION BEGAN TO SLIP. THERE WAS A SQUEALING NOISE COMING FROM THE REAR PASSENGER SIDE WHEEL. THE VEHICLE HAS NOT BEEN INSPECTED BY A MECHANIC.

05/26/2005 · Airbags
DT: CONSUMER STATED: HAD TO REPLACE THE CLOCK SPRING. CONTACTS INSIDE WERE BAD, IT MALFUNCTIONED, THE AIR BAG LIGHT WAS ON, HORN AND THE CRUISE CONTROL DIDN'T WORK. *AK