1996 Dodge Avenger recalls & complaints

Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.
Consequence: IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
Remedy: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.
Notes: AIRTEX RECALL NO. FP072007-1. THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY DAIMLERCHRYSLER OR MITSUBISHI. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Remedy: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.
Notes: OWNER NOTIFICATION BEGAN MAY 21, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.
Notes: OWNER NOTIFICATION BEGAN AUGUST 2, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHRYSLER AT 1-800-992-1997. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

03/02/2016 · Suspension
I WAS DRIVING AND THE RIGHT FRONT CONTROL LOWERBALL JOINT BROKE. THIS IS THE THIRD TIME THIS HAS HAPPENED. I CALLED DODGE DEALER.THEY SAID THEY FIX IT ONCE. THEY WON'T DO IT AGAIN. WELL IF THE PROBLEM STILL HAVING THEY NEED TO FIX IT RIGHT. I COULD OF BEEN KILLED. SOMETHING NEEDS TO BE DONE ABOUT THIS. NOW I WAS ON THE HWY

12/20/2007 · Engine · crash
MY SON DIED IN DEC 12,2002 IN A 1996 DODGE STEALTH TWO DAYS AFTER HE DIED I RECEIVED THE RECALL NOTICE. CAR LOST CONTROL ON FREEWAY AND WENT OFF ROAD AND ROLLED. HE JUST PUT A TRANSMISSION AND REPLACED CLUTCH, AND PUT IN NEW ENGINE THROUGH TRACY DODGE IN TRACY, CA. *TR

11/21/2007 · Suspension
THE LOWER CONTROL ARM ON THE LEFT SIDE IS GOING AND I'VE GONE TO DELUCA CHRYSLER IN HAVERHILL MA TWICE AND BOTH TIMES TOLD ME THAT IT WAS ALREADY SERVICED AND WHEN I ASKED HIM WHAT SIDE WAS SERVICED HE COULDN'T ANSWER ME AND I ASKED HIM IF THEY COULD CHECK MY SINCE IT SHOULD STILL BE COVERED UNDER RECALL WARRANTY HE TOLD ME NO AND JUST TODAY I WAS TOLD THAT…

10/04/2007 · Suspension · crash
TL*THE CONTACT OWNS A 1996 DODGE AVENGER. IN 2005, WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT LOST CONTROL AND THE VEHICLE PULLED TO THE RIGHT. SHE DEPRESSED THE BRAKE PEDAL, BUT THE VEHICLE WOULD NOT STOP. THE VEHICLE CRASHED INTO A DIRT HILL. SHE HAD THE VEHICLE TOWED TO A REPAIR SHOP AND WAS INFORMED THAT THE LOWER BALL JOINTS FAILED. A POLICE…

12/23/2006 · Suspension
I WAS DRIVING OUT OF A FAST FOOD RESTAURANT, AND WITHOUT ANY SIGN OR WARNING MY TIRE SNAPPED OFF MY AXLE! THE SERVICE DEPARTMENT AT THE LOCAL DODGE DEALERSHIP WAS CLOSED SO I HAD TO HAVE MY CAR TOWED TO ANOTHER PLACE THAT ALSO WORKS ON MY CAR WHENEVER I HAVE PROBLEMS. THE PART THAT NEEDED TO BE FIXED WAS THE "LOWER ARM CONTROL" ON THE DRIVER'S SIDE OF MY CA…

11/21/2005 · Suspension
PER TWO SEPARATE RECALL NOTICE I RECEIVED FROM DAIMLER CHRYSLER, I BROUGHT MY 1996 DODGE AVENGER INTO A DEALERSHIP TO HAVE THE LOWER LATERAL ARM BALL JOINTS INSPECTED AND RESEALED. UPON TAKING IT TO THE DEALERSHIP THEY INSPECTED AND BOTH TIMES THEY TOLD ME NO FURTHER WORK WAS NEEDED. SPECIFIC INSTRUCTIONS FROM DAIMLER CHRYSLER SAY,IF THE BALL JOINTS ARE N…

04/11/2005 · Engine
RIDING DOWN I 85 MY ENGINE JUST STOPPED DUE TO A TIMING BELT BREAKAGE. *AK

03/08/2005 · Suspension
DODGE AVENGER 1996, BALL JOINT AND AXLE BROKE. *BF RECALL CAMPAIGN# 99V066003. THIS PROBLEM OCCURRED WHILE THE VEHICLE WAS IN MOTION. THE CONSUMER EXPECTS REIMBURSEMENT. *SC THE CONSUMER RECEIVED THE RECALL LETTER IN THE MAIL 1 YEAR LATER. THE CONSUMER WAS DENIED REIMBURSEMENT BECAUSE THE RECEIPT WAS NOT TYPED IT WAS HAND WRITTEN. *JB